Author Topic: 50KVA generator on a 4 cylinder Dorman diesel engine  (Read 893 times)

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1262
  • Karma: +18/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
50KVA generator on a 4 cylinder Dorman diesel engine
« on: September 26, 2019, 09:44:26 AM »
I came by a small emergency generator that has been in service and still is, for a atleast 50-60 years.

The generator itself is a Titan København 50 KVA 3 phase 380 VAC, 76 Ampere and the diesel engine is a British Dorman 4LBIII 4 cylinder engine, which was also used in large excavators at the time.

The control panel was upgraded once, from a purely mechanical control, to a phase lock controller, which is still pretty old by todays standards.

http://www.kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics

Offline rikkitikkitavi

  • High Voltage Enthusiast
  • *
  • Posts: 39
  • Karma: +1/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #1 on: September 26, 2019, 11:10:35 AM »
"came by" ?
Do you have government approval to bring that home? :)

Must feel great to be able to run your largest coil even in case of a TEOWIKI :)

https://rib.msb.se/filer/pdf/28706.pdf they forgot this chapter, I will remind them :)

I dont know corresponding document with DEMA...


Cool anyhow, those old diesel engines.

I know some farmers with cattle farms that have backup power to run the milking robots for the cows etc, light/heat for the pigs etc , sometimes stand alone units and sometimes something you can run of your tractor power take-off system. As we know in Sweden what happens when the wind starts blowing in the trees and snapping power cables...


I also like that frequency meter with vibrating forks for frequency control . I have had the pleasure of doint that with a 6MVA generator once to the existing grid as a summer worker (I was not alone, the original operators was present but they let me throw the switch. You have to get both phase and frequency correct. Damn I was nervous ...

Mod edit: fixed broken link to PDF (had a - appended to the end)
« Last Edit: September 26, 2019, 04:53:31 PM by Hydron »
A man can not have too many variacs

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1262
  • Karma: +18/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #2 on: September 26, 2019, 12:02:24 PM »
"came by" ?
Do you have government approval to bring that home? :)

Yes, I came by it in my work, belongs to a customer. So it was just some pictures taken out of interest :)

I do however hope to get parts from a different decommissioned 400KVA generator set, at another non-related site, there will be a video on that if I succeed in getting access to it.
http://www.kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics

Offline johnf

  • High Voltage Enthusiast
  • *
  • Posts: 37
  • Karma: +0/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #3 on: September 26, 2019, 09:52:11 PM »
I  bought a bigger version from work a few years ago 150kVA 6 cylinder Dorman turbocharged
 [ Invalid Attachment ]
 [ Invalid Attachment ]  [ Invalid Attachment ]

Offline johnf

  • High Voltage Enthusiast
  • *
  • Posts: 37
  • Karma: +0/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #4 on: September 30, 2019, 09:02:26 PM »

Offline johnf

  • High Voltage Enthusiast
  • *
  • Posts: 37
  • Karma: +0/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #5 on: September 30, 2019, 09:07:12 PM »
I sold it a few years later as it was rotting away outside


Offline Experimentonomen

  • High Voltage Enthusiast
  • *
  • Posts: 6
  • Karma: +1/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #6 on: October 05, 2019, 05:02:04 PM »
It's not the same dorman as the cheapo shitty china replacement parts for cars, is it ?

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1262
  • Karma: +18/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #7 on: October 07, 2019, 09:40:44 AM »
I sold it a few years later as it was rotting away outside

Did you ever have it up and running? 150kVA is about the size I would like to own, on a trailer, but it would have to be a more modern generator set to get down in size for being dragged by a normal car :)

It's not the same dorman as the cheapo shitty china replacement parts for cars, is it ?

I guess that the brand Dorman, which was once a British produced product, is today, as many other brands, just a shadow of itself and either has a complete different business case today or the brand was sold off to some large conglomerate to take advantage of a known brand name.
http://www.kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics

Offline klugesmith

  • High Voltage Technician
  • ***
  • Posts: 130
  • Karma: +5/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #8 on: October 09, 2019, 09:04:18 PM »
Didn't think it worth starting a new thread...

Today in California, hundreds of thousands of people are without electric grid power.
Shut down on purpose, for the first time at this scale, because the weather forecast says critical risk of wildfire starting.  High temperature, low humidity, and fierce winds in the wooded and brushy hills where power lines run.

Maybe P G & E company is pushing it more than necessary.  Public support for higher electricity rates could bring more money to maintain thousands of miles of HV wires in fire country.  Enough to buy plenty of rakes, as recommended by national president after the record-breaking fires of 2017 and 2018.



Offline DICKEYBIRD

  • High Voltage Enthusiast
  • *
  • Posts: 12
  • Karma: +0/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #9 on: October 20, 2019, 10:39:59 PM »
I came by a small emergency generator that has been in service and still is, for a atleast 50-60 years...
Related thread: https://madmodder.net/index.php/topic,12989.0.html
Milton from Tennessee ya'll

Offline johnf

  • High Voltage Enthusiast
  • *
  • Posts: 37
  • Karma: +0/-0
    • View Profile
Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #10 on: October 21, 2019, 07:50:47 AM »
Yes my Dorman was 55 years old with 420 hours on thew clock
not quite broken in yet
sump heater and watere jacket heater to make starting easier with less wewar when going to full noise 10 seconds after start

High Voltage Forum

Re: 50KVA generator on a 4 cylinder Dorman diesel engine
« Reply #10 on: October 21, 2019, 07:50:47 AM »

 


* Recent Topics and Posts

post Finding accelerometer location inside a phone
[Smart Phones]
haversin
Today at 07:23:28 PM
post Re: GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
dj.cosmo.esq
Today at 07:41:18 AM
post Re: GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
ritaismyconscience
Today at 06:49:22 AM
post Re: GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
Today at 03:39:10 AM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
Quentief
Today at 02:32:55 AM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
klugesmith
Today at 02:10:34 AM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
Quentief
Today at 01:27:41 AM
post Re: GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Hydron
February 21, 2020, 08:00:10 PM
post Re: GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
February 21, 2020, 02:44:44 PM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
klugesmith
February 21, 2020, 07:21:13 AM
post Re: GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
ritaismyconscience
February 21, 2020, 06:11:32 AM
post Re: GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
February 21, 2020, 04:42:34 AM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
davekni
February 21, 2020, 04:37:53 AM
post Re: UV-cured cyanoacrylate glues?
[Light, Lasers and Optics]
Twospoons
February 21, 2020, 04:28:33 AM
post Re: UV-cured cyanoacrylate glues?
[Light, Lasers and Optics]
klugesmith
February 21, 2020, 04:21:31 AM
post GDT keeps on killing IGBTs
[Dual Resonant Solid State Tesla coils (DRSSTC)]
ritaismyconscience
February 21, 2020, 02:41:03 AM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
Quentief
February 21, 2020, 12:28:20 AM
post Re: UV-cured cyanoacrylate glues?
[Light, Lasers and Optics]
Twospoons
February 20, 2020, 09:45:21 PM
post Re: UV-cured cyanoacrylate glues?
[Light, Lasers and Optics]
klugesmith
February 20, 2020, 07:28:01 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Uspring
February 20, 2020, 02:06:26 PM
post Re: UV-cured cyanoacrylate glues?
[Light, Lasers and Optics]
shrad
February 20, 2020, 10:38:01 AM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
davekni
February 20, 2020, 05:14:43 AM
post Re: Is this flyback OK for my Plasma ball ?
[Transformer (Ferrite Core)]
davekni
February 20, 2020, 05:04:50 AM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
klugesmith
February 20, 2020, 04:47:41 AM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 19, 2020, 07:29:23 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 19, 2020, 06:47:55 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 19, 2020, 06:45:23 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Teravolt
February 19, 2020, 06:41:42 PM
post Re: Is this flyback OK for my Plasma ball ?
[Transformer (Ferrite Core)]
John123
February 19, 2020, 06:10:34 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
MRMILSTAR
February 19, 2020, 05:52:20 PM
post Re: Is this flyback OK for my Plasma ball ?
[Transformer (Ferrite Core)]
ElectroXa
February 19, 2020, 05:05:50 PM
post Re: Is this flyback OK for my Plasma ball ?
[Transformer (Ferrite Core)]
John123
February 19, 2020, 04:11:22 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Uspring
February 19, 2020, 02:03:12 PM
post Is this flyback OK for my Plasma ball ?
[Transformer (Ferrite Core)]
warmania
February 19, 2020, 11:24:58 AM
post Re: HP T620 Thin Client - PSU Hack And Windows PC Modification
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
latethannever
February 19, 2020, 11:00:15 AM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
rikkitikkitavi
February 19, 2020, 10:43:13 AM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 19, 2020, 06:54:14 AM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
klugesmith
February 19, 2020, 06:51:52 AM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
davekni
February 19, 2020, 03:53:13 AM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
ElectroXa
February 18, 2020, 09:44:25 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
MRMILSTAR
February 18, 2020, 09:34:06 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 18, 2020, 08:27:31 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Weston
February 18, 2020, 07:55:14 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 18, 2020, 07:32:04 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
klugesmith
February 18, 2020, 05:58:39 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
MRMILSTAR
February 18, 2020, 05:16:55 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 18, 2020, 04:19:37 PM
post Re: Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Mads Barnkob
February 18, 2020, 04:12:11 PM
post Re: 230 volts spark gap
[Spark Gap Tesla Coils (SGTC)]
Quentief
February 18, 2020, 01:25:06 PM
post Help!Capacitor that burns out after a while!
[Voltage Multipliers]
Peregrine
February 18, 2020, 10:40:58 AM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal