Author Topic: Weird Thing During Troubleshooting SSTC! Please help me identity what's going on  (Read 232 times)

Offline hashtala

  • High Voltage Enthusiast
  • *
  • Posts: 5
  • Karma: +0/-0
    • View Profile
Hello, this is my first time building a tesla coil. (Im not new to electronics but I am new to tesla coil)



This is my schematic.  (Single power transistor 2D2499)

https://ibb.co/mH873T1

I generate signal using a microcontroller. However, for the safety, before rectifying 220 AC. I have ligh bulb (65 ohm) connected in series
for short circuit protection. Basically, if transistor would blow up, light bulb would turn on.

However there is very weird thing going on!

When I turn the system on lightbulb turn on for a short time (until capacitors charge) and everything seems normal. then I start generating square wave from micronotroller and lightbulb TURNS ON!!!

On lower frequencies (4-100khz) it is very bright.
However about at RESONANCE FREQUENCY it is emitting much less light! but I do not have any sparks on sound from tesla coil. It cannot even turn on fluorescent light.

What is going on ? Is my lightbulb limiting current ?
If I remove it my circuit breaker might go crazy. Any advice ???




Offline davekni

  • High Voltage Senior
  • *****
  • Posts: 852
  • Karma: +39/-0
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Two paths for progress come to mind.  One is to read more on this forum and other posted design plans.  Learn how Tesla coils work, perhaps starting with driving resonant circuits.

The other is to buy a cheap scope and measure what's happening.  Related, download and learn an analog simulator.  There are several free ones.  My preferred one is LTSpice.  Then you can see what should happen and compare it to what you measure with a scope.  (Even if you don't have funds to purchase a scope, simulation is a great way to understand your design and other designs you will find here.)
David Knierim

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1615
  • Karma: +29/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
You need to post much more pictures of your setup and as Dave suggests, learn more about basic resonant circuits like a well-known SSTC circuit.

Start out with a simple SSTC like http://kaizerpowerelectronics.dk/tesla-coils/kaizer-sstc-i/ or http://loneoceans.com/labs/sstc2/

You are most likely driving the poor not-very-fitted-for-the-job transistor at a too low frequency for the secondary coil + topload capacitance resonant frequency. You need to use some proper MOSFETs/IGBTs in order to drive the current needed at the high frequencies, without your power electronics burning to the ground.
https://kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics
https://www.youtube.com/KaizerPowerElectronicsDk60/join - Please consider supporting the forum, websites and youtube channel!

High Voltage Forum


 


* Recent Topics and Posts

post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
zytra
Today at 05:00:50 AM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
davekni
Today at 04:03:12 AM
post Just a noob with some HV concerns...
[Beginners]
MrScrOggs
Today at 03:07:11 AM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
zytra
Today at 02:57:27 AM
post Re: compact midi interrupter
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
TMaxElectronics
Today at 12:06:44 AM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
davekni
January 18, 2021, 11:56:31 PM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
Alberto
January 18, 2021, 11:50:22 PM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
klugesmith
January 18, 2021, 10:30:15 PM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
zytra
January 18, 2021, 10:03:46 PM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
davekni
January 18, 2021, 09:58:44 PM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
zytra
January 18, 2021, 08:52:29 PM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
davekni
January 18, 2021, 07:08:09 PM
post Re: Adding interrupter Self oscillating tesla coil
[Beginners]
davekni
January 18, 2021, 06:49:28 PM
post Re: Alcatel Lucent B4 RRH2x60-4R teardown and reverse engineering
[Radio Frequency]
Da_Stier
January 18, 2021, 06:12:44 PM
post Re: Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
klugesmith
January 18, 2021, 04:53:23 PM
post Adding interrupter Self oscillating tesla coil
[Beginners]
arto
January 18, 2021, 11:54:54 AM
post Re: Segmented PTFE Secondary, Plasma Ball project
[Transformer (Ferrite Core)]
zytra
January 18, 2021, 08:27:18 AM
post Re: Self Oscillating Half Bridge Wonder
[Solid State Tesla Coils (SSTC)]
Acid Byte
January 18, 2021, 06:57:06 AM
post Re: Segmented PTFE Secondary, Plasma Ball project
[Transformer (Ferrite Core)]
davekni
January 18, 2021, 06:43:19 AM
post Re: Segmented PTFE Secondary, Plasma Ball project
[Transformer (Ferrite Core)]
zytra
January 18, 2021, 05:48:27 AM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
klugesmith
January 18, 2021, 01:03:48 AM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
Alberto
January 18, 2021, 12:26:26 AM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
davekni
January 17, 2021, 11:29:04 PM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
Alberto
January 17, 2021, 09:55:24 PM
post Re: Segmented PTFE Secondary, Plasma Ball project
[Transformer (Ferrite Core)]
zytra
January 17, 2021, 09:34:21 PM
post Re: Segmented PTFE Secondary, Plasma Ball project
[Transformer (Ferrite Core)]
davekni
January 17, 2021, 08:51:50 PM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
davekni
January 17, 2021, 08:04:54 PM
post Re: compact midi interrupter
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
tophat
January 17, 2021, 05:40:59 PM
post Re: Schlieren images projected onto a wall (no camera)
[Light, Lasers and Optics]
Uspring
January 17, 2021, 05:12:45 PM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
SteveN87
January 17, 2021, 02:20:09 PM
post Re: First SSTC build - some questions
[Solid State Tesla Coils (SSTC)]
zytra
January 17, 2021, 05:56:05 AM
post Segmented PTFE Secondary, Large Plasma Ball project
[Transformer (Ferrite Core)]
zytra
January 17, 2021, 05:55:11 AM
post Re: First SSTC build - some questions
[Solid State Tesla Coils (SSTC)]
davekni
January 17, 2021, 03:50:27 AM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
davekni
January 17, 2021, 03:37:28 AM
post Re: First SSTC build - some questions
[Solid State Tesla Coils (SSTC)]
zytra
January 17, 2021, 01:48:10 AM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
Alberto
January 16, 2021, 11:21:13 PM
post Re: I started making a drsstc
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
January 16, 2021, 10:09:21 PM
post Re: I started making a drsstc
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Miki_407
January 16, 2021, 09:38:08 PM
post Re: Schlieren images projected onto a wall (no camera)
[Light, Lasers and Optics]
davekni
January 16, 2021, 09:27:25 PM
post Re: UD2.9 Troubleshooting Help
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
January 16, 2021, 09:05:23 PM
post Re: UD2.9 Troubleshooting Help
[Dual Resonant Solid State Tesla coils (DRSSTC)]
GKnapp
January 16, 2021, 07:44:41 PM
post Re: I started making a drsstc
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
January 16, 2021, 07:06:13 PM
post Re: UD2.9 Troubleshooting Help
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
January 16, 2021, 06:48:05 PM
post Re: I started making a drsstc
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Miki_407
January 16, 2021, 06:38:11 PM
post Re: UD2.9 Troubleshooting Help
[Dual Resonant Solid State Tesla coils (DRSSTC)]
GKnapp
January 16, 2021, 06:23:53 PM
post Re: Schlieren images projected onto a wall (no camera)
[Light, Lasers and Optics]
klugesmith
January 16, 2021, 06:23:10 PM
post Re: UD2.9 Troubleshooting Help
[Dual Resonant Solid State Tesla coils (DRSSTC)]
GKnapp
January 16, 2021, 03:28:14 PM
post Re: First SSTC build - some questions
[Solid State Tesla Coils (SSTC)]
davekni
January 16, 2021, 05:09:53 AM
post Re: how to run these guys?
[Transformer (Ferrite Core)]
davekni
January 16, 2021, 05:00:46 AM
post Re: UD2.9 Troubleshooting Help
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
January 16, 2021, 04:56:31 AM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal