Author Topic: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...  (Read 1752 times)

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1822
  • Karma: +47/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« on: October 08, 2018, 09:25:14 PM »
obvious click-bait head line, but I got no plans... so what to call to it :)

I got these inverter boards from a large 60 kVA UPS system where each cabinet had 4 of these modules inside.

It consisted of 10 FS35R12 IGBT bricks, which is a 3 phased full bridge module, but here they used 2 of these modules for a halfbridge where all 3 "halfbridges" inside the module was used in parallel.

There is a common DC bus supply for the 3 phases, the other 2 halfbridge inverters was either PFC or intermediate inverters, so I removed those and I now have a board with 3 halfbridges that consists of 3 parallel halfbridges.

So if I parallel these 3 outputs I would have 9 parallel halfbridges where each igbt die is rated for 70 Apeak, which is a little low, but with the huge thermal mass that 9 parallel bridges gives, this could properly be pushed above 100A without too much trouble.

At these low peak currents I think there is only one plan for these boards, a QCWDRSSTC. I could try even longer than normal on-times due to the low peak current or as I have 5 of these boards and extra IGBT modules, I could run 2 or more interleaved to allow more time for cooling.



Anyone got comments or suggestions to this plan?
« Last Edit: August 03, 2021, 11:29:28 AM by Mads Barnkob »
https://kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics
https://www.youtube.com/KaizerPowerElectronicsDk60/join - Please consider supporting the forum, websites and youtube channel!

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1822
  • Karma: +47/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
Re: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« Reply #1 on: August 03, 2021, 07:55:07 AM »
I recently found my stash of these boards at the back of a shelf in the work shop.

Back in 2018, this did not spark the interest or imagination of the forum, is it any different here in 2021?

If I do not end up with a good plan for it, its going back to the scrap yard :)
https://kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics
https://www.youtube.com/KaizerPowerElectronicsDk60/join - Please consider supporting the forum, websites and youtube channel!

Offline Da_Stier

  • High Voltage Technician
  • ***
  • Posts: 137
  • Karma: +9/-0
    • View Profile
Re: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« Reply #2 on: August 03, 2021, 10:35:58 AM »
It should be interesting to try and build a beefy SMPS , shouldn't it?
A power supply that can provide something like 0 to 60V with 1500W or something like this.


High Voltage Forum

Re: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« Reply #2 on: August 03, 2021, 10:35:58 AM »

 


* Recent Topics and Posts

post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
Today at 09:08:00 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
fh89
Today at 07:39:29 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
Today at 05:28:46 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
Today at 03:32:45 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
futurist
Today at 01:26:15 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
fh89
September 17, 2021, 11:41:50 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
alexhanyuan
September 17, 2021, 08:23:44 PM
post Re: Syntherrupter - A Feature-rich, Polyphonic Interrupter
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
Max
September 17, 2021, 06:44:43 PM
post Re: Large Rectifier Tube
[General Chat]
Benbmw
September 17, 2021, 05:46:05 PM
post Re: Large Rectifier Tube
[General Chat]
Benbmw
September 17, 2021, 04:26:04 PM
post Re: Syntherrupter - A Feature-rich, Polyphonic Interrupter
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
Mathieu
September 17, 2021, 03:42:10 PM
post Re: High power clean audio SSTC
[Solid State Tesla Coils (SSTC)]
AstRii
September 17, 2021, 10:56:31 AM
post Re: Large Rectifier Tube
[General Chat]
johnf
September 17, 2021, 10:06:53 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Magneticitist
September 17, 2021, 08:51:50 AM
post Re: Large Rectifier Tube
[General Chat]
Benbmw
September 17, 2021, 07:56:29 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 17, 2021, 07:26:06 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
johnf
September 17, 2021, 06:45:00 AM
post Re: Driverless MOSFET SSTC
[Beginners]
johnf
September 17, 2021, 06:11:27 AM
post Re: High power clean audio SSTC
[Solid State Tesla Coils (SSTC)]
davekni
September 17, 2021, 05:49:54 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 17, 2021, 05:26:51 AM
post Driverless MOSFET SSTC
[Beginners]
oels12
September 17, 2021, 04:41:56 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Magneticitist
September 17, 2021, 03:12:39 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 17, 2021, 02:20:14 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Duane B
September 17, 2021, 01:23:24 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 17, 2021, 12:41:16 AM
post Re: High power clean audio SSTC
[Solid State Tesla Coils (SSTC)]
AstRii
September 16, 2021, 11:08:39 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Duane B
September 16, 2021, 11:05:56 PM
post Re: High power clean audio SSTC
[Solid State Tesla Coils (SSTC)]
Duane B
September 16, 2021, 10:55:32 PM
post High power clean audio SSTC
[Solid State Tesla Coils (SSTC)]
AstRii
September 16, 2021, 09:38:15 PM
post Re: The Therac 25
[General Chat]
TMaxElectronics
September 16, 2021, 10:22:13 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 16, 2021, 07:41:05 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 16, 2021, 06:19:40 AM
post Re: Linear Induction Launcher
[Induction Launchers, Coil Guns and Rails guns]
davekni
September 16, 2021, 06:15:58 AM
post Re: Indukcion heter problem
[Electronic Circuits]
davekni
September 16, 2021, 06:09:24 AM
post Re: Indukcion heter problem
[Electronic Circuits]
johnf
September 16, 2021, 04:25:14 AM
post Re: Resistance to protect flybacks, etc.
[Voltage Multipliers]
abstruse1
September 16, 2021, 01:35:02 AM
post Re: Indukcion heter problem
[Electronic Circuits]
balazs
September 15, 2021, 10:32:11 PM
post Re: Indukcion heter problem
[Electronic Circuits]
Uspring
September 15, 2021, 09:43:01 PM
post Re: Resistance to protect flybacks, etc.
[Voltage Multipliers]
johnnyzoo
September 15, 2021, 08:20:53 PM
post Re: The Therac 25
[General Chat]
johnnyzoo
September 15, 2021, 08:09:01 PM
post Re: Indukcion heter problem
[Electronic Circuits]
balazs
September 15, 2021, 07:38:23 PM
post Resistance to protect flybacks, etc.
[Voltage Multipliers]
abstruse1
September 15, 2021, 04:42:06 PM
post Re: Indukcion heter problem
[Electronic Circuits]
Da_Stier
September 15, 2021, 03:00:07 PM
post maxwell 35349 73 nf 50 kv for sale
[Sell / Buy / Trade]
paulj
September 15, 2021, 11:36:40 AM
post Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 15, 2021, 08:40:19 AM
post Re: Linear Induction Launcher
[Induction Launchers, Coil Guns and Rails guns]
Benbmw
September 15, 2021, 08:12:34 AM
post Re: Linear Induction Launcher
[Induction Launchers, Coil Guns and Rails guns]
davekni
September 15, 2021, 05:56:54 AM
post Re: Indukcion heter problem
[Electronic Circuits]
davekni
September 15, 2021, 05:33:37 AM
post Re: repair of Panasonic microwave inverter
[Electronic Circuits]
imp
September 15, 2021, 02:31:24 AM
post Re: The Therac 25
[General Chat]
imp
September 15, 2021, 02:21:55 AM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal