Author Topic: Server PSU OPV Hack - Fujitsu DPS-800GB-5 A  (Read 1721 times)

Offline v.coelho

  • High Voltage Enthusiast
  • *
  • Posts: 2
  • Karma: +0/-0
    • View Profile
Server PSU OPV Hack - Fujitsu DPS-800GB-5 A
« on: September 23, 2020, 01:11:50 PM »
Hello,
I start by saying that I am new to this theme of Server PSU. But I bought a Server PSU to use as a power supply for my CB radio, to use with 13.8V, the PSU I bought was Fujitsu DPS-800GB-5 A (as you can see in the pictures).
I managed to turn on the PSU by connecting pins 31-34 and 26-GND. However, the problems started when I tried to increase the output voltage using a potentiometer between the 32-GND pins, just above 13.3v the overvoltage protection circuit disconnects the PSU output.
After some research I found out that a possible solution would be to disconnect one of the pins from the OVP chip, but I can't find the OVP chip on this PSU.
Can someone help me?

Offline Zipdox

  • High Voltage Technician
  • ***
  • Posts: 143
  • Karma: +1/-0
    • View Profile
    • Zipdox
Re: Server PSU OPV Hack - Fujitsu DPS-800GB-5 A
« Reply #1 on: September 23, 2020, 01:34:42 PM »
Can you make some internal photos? Preferably high quality so we can read ICs.

Offline petespaco

  • High Voltage Engineer
  • ****
  • Posts: 220
  • Karma: +11/-0
    • View Profile
    • French Creek Valley Activities
Re: Server PSU OPV Hack - Fujitsu DPS-800GB-5 A
« Reply #2 on: September 23, 2020, 04:26:34 PM »
I haven't used a CB radio in a car since about 1980, but I don't understand why NEED 13.8 volts.  The thing should run off a car battery with the engine off, shouldn't it?  I'd think that anything over about 12.0 volts should be fine.

Pete Stanaitis
---------------

Offline v.coelho

  • High Voltage Enthusiast
  • *
  • Posts: 2
  • Karma: +0/-0
    • View Profile
Re: Server PSU OPV Hack - Fujitsu DPS-800GB-5 A
« Reply #3 on: September 24, 2020, 01:11:27 PM »
Here is a picture of the chips in the PSU I marked the references

Offline klugesmith

  • High Voltage Engineer
  • ****
  • Posts: 387
  • Karma: +12/-0
    • View Profile
Re: Server PSU OPV Hack - Fujitsu DPS-800GB-5 A
« Reply #4 on: September 24, 2020, 03:02:00 PM »
I agree with Pete.  Set the PSU to 13 V and start using the radio.

At 13.0 you are most of the way to nominal voltage of the radio set. Probably within the radio's rating.
You retain the benefit of OVP, so a random component failure in PSU won't destroy the radio.

Disabling OVP can be more excusable than bypassing a fuse so you can get a little more current out of something.
Am reminded of getting 120 volts directly from car engine alternators, by changing the rectifier diodes and modifying the voltage regulation (field current control).

At least one 4-channel amplifier IC for OEM car audio equipment needs 14.4 V DC to reach its nominal power output.
What's the nominal DC voltage for great big car amplifiers and associated ultracapacitors? 

« Last Edit: September 24, 2020, 03:22:01 PM by klugesmith »

Offline Bjoe10

  • High Voltage Enthusiast
  • *
  • Posts: 1
  • Karma: +0/-0
    • View Profile
Re: Server PSU OPV Hack - Fujitsu DPS-800GB-5 A
« Reply #5 on: September 02, 2021, 09:12:12 PM »
Hi! I got the same power supply and i want to remove the ovp because i need 14v to power my project

Does somebody has any idea?

High Voltage Forum

Re: Server PSU OPV Hack - Fujitsu DPS-800GB-5 A
« Reply #5 on: September 02, 2021, 09:12:12 PM »

 


* Recent Topics and Posts

post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Netzpfuscher
Today at 07:26:30 AM
post Tesla plate
[General Chat]
Duane B
Today at 01:54:49 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2021, 09:08:23 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Uspring
September 23, 2021, 07:09:23 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2021, 05:46:38 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 23, 2021, 11:12:25 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Netzpfuscher
September 23, 2021, 08:49:51 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2021, 06:15:34 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 23, 2021, 05:48:40 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Uspring
September 22, 2021, 07:21:12 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 22, 2021, 10:41:20 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 22, 2021, 07:07:48 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 22, 2021, 05:26:40 AM
post Re: Measuring TC secondary parameters
[General Chat]
MRMILSTAR
September 22, 2021, 05:14:30 AM
post Measuring TC secondary parameters
[General Chat]
Duane B
September 22, 2021, 05:01:22 AM
post Re: Load resistance and discharge terminal for my 14-stage CW multiplier
[Voltage Multipliers]
MRMILSTAR
September 21, 2021, 10:33:34 PM
post Re: Futurist's DRSSTC 0.5
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
September 21, 2021, 07:21:50 PM
post Re: Load resistance and discharge terminal for my 14-stage CW multiplier
[Voltage Multipliers]
klugesmith
September 21, 2021, 05:24:35 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
futurist
September 21, 2021, 04:18:47 PM
post Load resistance and discharge terminal for my 14-stage CW multiplier
[Voltage Multipliers]
MRMILSTAR
September 21, 2021, 06:30:44 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 21, 2021, 06:04:52 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
fh89
September 21, 2021, 03:56:28 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
johnnyzoo
September 20, 2021, 09:24:10 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Uspring
September 20, 2021, 05:07:43 PM
post Re: Large Rectifier Tube
[General Chat]
Benbmw
September 20, 2021, 04:12:27 PM
post Re: Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Chrisader
September 20, 2021, 10:40:33 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 10:39:59 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
futurist
September 20, 2021, 10:38:31 AM
post Re: Large Rectifier Tube
[General Chat]
klugesmith
September 20, 2021, 07:07:55 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 06:03:57 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 20, 2021, 05:31:57 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 04:59:17 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 04:28:03 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 20, 2021, 12:53:39 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
johnnyzoo
September 19, 2021, 11:09:37 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
AstRii
September 19, 2021, 09:47:14 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 19, 2021, 08:28:05 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 19, 2021, 08:19:01 PM
post Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
AstRii
September 19, 2021, 07:58:09 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 19, 2021, 03:16:40 PM
post Re: Driverless MOSFET SSTC
[Beginners]
AstRii
September 19, 2021, 01:32:47 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 19, 2021, 10:15:24 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Magneticitist
September 19, 2021, 06:32:18 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 19, 2021, 06:06:44 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 19, 2021, 04:14:18 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Magneticitist
September 18, 2021, 11:33:37 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AstRii
September 18, 2021, 10:42:45 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
fh89
September 18, 2021, 09:05:03 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
fh89
September 18, 2021, 09:00:32 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
AstRii
September 18, 2021, 08:34:15 PM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal