Author Topic: Micro-power continuity checker.  (Read 152 times)

Offline davekni

  • High Voltage Expert
  • ******
  • Posts: 1221
  • Karma: +60/-0
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Micro-power continuity checker.
« on: July 20, 2021, 05:37:36 AM »
About 15 years ago I built a couple simple continuity checkers, one for home and one for work.  They apply low voltage to avoid forward diode junction conduction and light an LED when resistance is below about 10 ohms.  Power is from a single 18650 LiIon cell.  I find them very convenient - probing an ECB to see which side of a bypass capacitor is ground, checking for hidden solder bridges under parts, etc.  However, these draw enough quiescent current that an on/off switch is necessary.

Last weekend I made two new continuity checkers drawing only 10uA quiescent.  Also reduced threshold resistance to between 1 and 2 ohms.  No on/off switch to forget to switch and battery life of 5-10 years between charges. :)

Normal people would use a micro-power opamp for such a circuit.  Being abnormal and fond of discrete circuity, mine uses three transistors instead:



Dremel-tool cut circuit board:



Finished continuity checker.  Most of the volume is the 18650 LiIon cell.  Board and probe tip are taped to the cell.





The circuit can easily be made in reverse, using PNP transistors and an NFET.  (Actually, one of the two I made is reversed.)  Power supply is reversed too.  I prefer the version shown here, as one probe is the negative supply which is battery case.  Makes accidental shorts of the battery less likely.
David Knierim

Offline klugesmith

  • High Voltage Engineer
  • ****
  • Posts: 378
  • Karma: +12/-0
    • View Profile
Re: Micro-power continuity checker.
« Reply #1 on: July 20, 2021, 06:24:29 PM »
Applause!  What's the open circuit voltage and short circuit current at the probe tips?

The first electronic project I remember making, more than 50 years ago, was a continuity checker that beeped.  Circuit, out of a magazine, had one or two transistors and a tiny transformer IIRC. Perhaps a blocking oscillator like that in Joule Thief circuit. I think it predated the invention of NE555.
« Last Edit: July 20, 2021, 06:30:55 PM by klugesmith »

Offline davekni

  • High Voltage Expert
  • ******
  • Posts: 1221
  • Karma: +60/-0
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Re: Micro-power continuity checker.
« Reply #2 on: July 21, 2021, 03:50:33 AM »
Quote
Applause!  What's the open circuit voltage and short circuit current at the probe tips?
Thank you for the appreciation!  Voltage with a 10meg meter load is 127mV.  Voltage across a 1.5ohm resistor where the LED starts glowing is 25mV.  LED is fully on by 1.0 ohms and 20mV.
David Knierim

High Voltage Forum

Re: Micro-power continuity checker.
« Reply #2 on: July 21, 2021, 03:50:33 AM »

 


* Recent Topics and Posts

post Re: Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
Today at 10:15:30 PM
post CW Help -- too much info to digest
[Voltage Multipliers]
abstruse1
Today at 06:16:53 PM
post Re: Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Chrisader
Today at 04:16:11 PM
post Re: Gate driver for big IGBTs
[Electronic Circuits]
davekni
Today at 05:38:42 AM
post Gate driver for big IGBTs
[Electronic Circuits]
TMaxElectronics
Today at 02:15:25 AM
post Re: Modified VTTC for induction heating
[Vacuum Tube Tesla Coils (VTTC)]
dbach
July 24, 2021, 11:38:33 PM
post Re: Modified VTTC for induction heating
[Vacuum Tube Tesla Coils (VTTC)]
Mads Barnkob
July 24, 2021, 11:29:15 PM
post Re: repair of Panasonic microwave inverter
[Electronic Circuits]
Twospoons
July 24, 2021, 10:41:38 PM
post Modified VTTC for induction heating
[Vacuum Tube Tesla Coils (VTTC)]
dbach
July 24, 2021, 09:18:42 PM
post Re: repair of Panasonic microwave inverter
[Electronic Circuits]
Mads Barnkob
July 24, 2021, 08:08:36 PM
post Re: Tesla Coil Show Controller Project
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Max
July 24, 2021, 11:13:18 AM
post Re: repair of Panasonic microwave inverter
[Electronic Circuits]
Weston
July 24, 2021, 10:08:34 AM
post Re: Horrible waveforms advice--just bad test setup?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
July 24, 2021, 03:20:42 AM
post Re: repair of Panasonic microwave inverter
[Electronic Circuits]
Twospoons
July 24, 2021, 03:16:27 AM
post 3kW Cisco Server Supply teardown and help needed
[Electronic Circuits]
Da_Stier
July 23, 2021, 09:23:11 PM
post Re: IGBT question
[Dual Resonant Solid State Tesla coils (DRSSTC)]
thedoc298
July 23, 2021, 08:05:58 PM
post Re: IGBT question
[Dual Resonant Solid State Tesla coils (DRSSTC)]
futurist
July 23, 2021, 07:02:18 PM
post Re: IGBT question
[Dual Resonant Solid State Tesla coils (DRSSTC)]
thedoc298
July 23, 2021, 05:33:57 PM
post Re: Horrible waveforms advice--just bad test setup?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
GKnapp
July 23, 2021, 04:51:37 PM
post Re: Horrible waveforms advice--just bad test setup?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
July 23, 2021, 03:52:46 AM
post Re: IGBT question
[Dual Resonant Solid State Tesla coils (DRSSTC)]
thedoc298
July 22, 2021, 10:59:32 PM
post Re: Horrible waveforms advice--just bad test setup?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
GKnapp
July 22, 2021, 08:50:34 PM
post Re: IGBT question
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
July 22, 2021, 08:47:23 PM
post Help needed - which IGBT module to buy
[Dual Resonant Solid State Tesla coils (DRSSTC)]
thedoc298
July 22, 2021, 07:01:24 PM
post Re: Horrible waveforms advice--just bad test setup?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
July 22, 2021, 06:50:07 AM
post Re: Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
July 22, 2021, 06:39:37 AM
post Re: Horrible waveforms advice--just bad test setup?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
alan sailer
July 21, 2021, 07:55:03 PM
post Horrible waveforms advice--just bad test setup?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
GKnapp
July 21, 2021, 06:34:13 PM
post Re: Global shutter synchronized to arcs?
[DSLR]
Uspring
July 21, 2021, 05:10:18 PM
post Re: Tesla Coil Show Controller Project
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
July 21, 2021, 12:42:29 PM
post Re: Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Chrisader
July 21, 2021, 08:15:00 AM
post Re: Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
July 21, 2021, 04:57:04 AM
post Re: Micro-power continuity checker.
[Electronic Circuits]
davekni
July 21, 2021, 03:50:33 AM
post Re: Skm flyback destroyer 🤗
[Transformer (Ferrite Core)]
oneKone
July 21, 2021, 01:50:19 AM
post Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Chrisader
July 20, 2021, 10:06:14 PM
post Re: Micro-power continuity checker.
[Electronic Circuits]
klugesmith
July 20, 2021, 06:24:29 PM
post Micro-power continuity checker.
[Electronic Circuits]
davekni
July 20, 2021, 05:37:36 AM
post Re: Help needed with SSTC. First TC build
[Solid State Tesla Coils (SSTC)]
davekni
July 20, 2021, 05:08:24 AM
post Re: Global shutter synchronized to arcs?
[DSLR]
davekni
July 20, 2021, 04:43:05 AM
post Re: Global shutter synchronized to arcs?
[DSLR]
TMaxElectronics
July 20, 2021, 12:09:36 AM
post Re: Help needed with SSTC. First TC build
[Solid State Tesla Coils (SSTC)]
AstRii
July 19, 2021, 11:13:13 PM
post Another question on CT Feedback
[Solid State Tesla Coils (SSTC)]
Maverikie
July 19, 2021, 08:56:04 PM
post Re: Sync RSG motor problems - help and thoughts needed
[Spark Gap Tesla Coils (SGTC)]
newage
July 19, 2021, 07:09:56 PM
post Re: Global shutter synchronized to arcs?
[DSLR]
klugesmith
July 19, 2021, 06:49:08 PM
post Re: Sync RSG motor problems - help and thoughts needed
[Spark Gap Tesla Coils (SGTC)]
klugesmith
July 19, 2021, 04:39:05 PM
post Global shutter synchronized to arcs?
[DSLR]
davekni
July 19, 2021, 06:32:35 AM
post Re: Sync RSG motor problems - help and thoughts needed
[Spark Gap Tesla Coils (SGTC)]
MRMILSTAR
July 19, 2021, 05:22:51 AM
post Re: Sync RSG motor problems - help and thoughts needed
[Spark Gap Tesla Coils (SGTC)]
newage
July 19, 2021, 04:24:38 AM
post Re: a typical sstc half bridge design, any considerations or tips?
[Solid State Tesla Coils (SSTC)]
eli
July 19, 2021, 12:35:18 AM
post Re: a typical sstc half bridge design, any considerations or tips?
[Solid State Tesla Coils (SSTC)]
Mads Barnkob
July 19, 2021, 12:15:43 AM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal