Author Topic: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...  (Read 1765 times)

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1823
  • Karma: +47/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« on: October 08, 2018, 09:25:14 PM »
obvious click-bait head line, but I got no plans... so what to call to it :)

I got these inverter boards from a large 60 kVA UPS system where each cabinet had 4 of these modules inside.

It consisted of 10 FS35R12 IGBT bricks, which is a 3 phased full bridge module, but here they used 2 of these modules for a halfbridge where all 3 "halfbridges" inside the module was used in parallel.

There is a common DC bus supply for the 3 phases, the other 2 halfbridge inverters was either PFC or intermediate inverters, so I removed those and I now have a board with 3 halfbridges that consists of 3 parallel halfbridges.

So if I parallel these 3 outputs I would have 9 parallel halfbridges where each igbt die is rated for 70 Apeak, which is a little low, but with the huge thermal mass that 9 parallel bridges gives, this could properly be pushed above 100A without too much trouble.

At these low peak currents I think there is only one plan for these boards, a QCWDRSSTC. I could try even longer than normal on-times due to the low peak current or as I have 5 of these boards and extra IGBT modules, I could run 2 or more interleaved to allow more time for cooling.



Anyone got comments or suggestions to this plan?
« Last Edit: August 03, 2021, 11:29:28 AM by Mads Barnkob »
https://kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics
https://www.youtube.com/KaizerPowerElectronicsDk60/join - Please consider supporting the forum, websites and youtube channel!

Offline Mads Barnkob

  • Administrator
  • High Voltage Expert
  • *****
  • Posts: 1823
  • Karma: +47/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
Re: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« Reply #1 on: August 03, 2021, 07:55:07 AM »
I recently found my stash of these boards at the back of a shelf in the work shop.

Back in 2018, this did not spark the interest or imagination of the forum, is it any different here in 2021?

If I do not end up with a good plan for it, its going back to the scrap yard :)
https://kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics
https://www.youtube.com/KaizerPowerElectronicsDk60/join - Please consider supporting the forum, websites and youtube channel!

Offline Da_Stier

  • High Voltage Technician
  • ***
  • Posts: 138
  • Karma: +9/-0
    • View Profile
Re: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« Reply #2 on: August 03, 2021, 10:35:58 AM »
It should be interesting to try and build a beefy SMPS , shouldn't it?
A power supply that can provide something like 0 to 60V with 1500W or something like this.


High Voltage Forum

Re: Up to 9 half-bridges of FS35R12 IGBTs in parallel, per board...
« Reply #2 on: August 03, 2021, 10:35:58 AM »

 


* Recent Topics and Posts

post prodc9 interrupter plexi case
[Dual Resonant Solid State Tesla coils (DRSSTC)]
costas_p
September 24, 2021, 07:14:53 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Uspring
September 24, 2021, 05:37:56 PM
post Re: Tesla plate
[General Chat]
Benbmw
September 24, 2021, 05:20:01 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Netzpfuscher
September 24, 2021, 07:26:30 AM
post Tesla plate
[General Chat]
Duane B
September 24, 2021, 01:54:49 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2021, 09:08:23 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Uspring
September 23, 2021, 07:09:23 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2021, 05:46:38 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 23, 2021, 11:12:25 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Netzpfuscher
September 23, 2021, 08:49:51 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2021, 06:15:34 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 23, 2021, 05:48:40 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Uspring
September 22, 2021, 07:21:12 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 22, 2021, 10:41:20 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 22, 2021, 07:07:48 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 22, 2021, 05:26:40 AM
post Re: Measuring TC secondary parameters
[General Chat]
MRMILSTAR
September 22, 2021, 05:14:30 AM
post Measuring TC secondary parameters
[General Chat]
Duane B
September 22, 2021, 05:01:22 AM
post Re: Load resistance and discharge terminal for my 14-stage CW multiplier
[Voltage Multipliers]
MRMILSTAR
September 21, 2021, 10:33:34 PM
post Re: Futurist's DRSSTC 0.5
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
September 21, 2021, 07:21:50 PM
post Re: Load resistance and discharge terminal for my 14-stage CW multiplier
[Voltage Multipliers]
klugesmith
September 21, 2021, 05:24:35 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
futurist
September 21, 2021, 04:18:47 PM
post Load resistance and discharge terminal for my 14-stage CW multiplier
[Voltage Multipliers]
MRMILSTAR
September 21, 2021, 06:30:44 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 21, 2021, 06:04:52 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
fh89
September 21, 2021, 03:56:28 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
johnnyzoo
September 20, 2021, 09:24:10 PM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Uspring
September 20, 2021, 05:07:43 PM
post Re: Large Rectifier Tube
[General Chat]
Benbmw
September 20, 2021, 04:12:27 PM
post Re: Proper phase lead adjustment at the input
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Chrisader
September 20, 2021, 10:40:33 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 10:39:59 AM
post Re: BrOdin coil - High power Big sparks!
[Dual Resonant Solid State Tesla coils (DRSSTC)]
futurist
September 20, 2021, 10:38:31 AM
post Re: Large Rectifier Tube
[General Chat]
klugesmith
September 20, 2021, 07:07:55 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 06:03:57 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 20, 2021, 05:31:57 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 04:59:17 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 20, 2021, 04:28:03 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 20, 2021, 12:53:39 AM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
johnnyzoo
September 19, 2021, 11:09:37 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
AstRii
September 19, 2021, 09:47:14 PM
post Re: Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 19, 2021, 08:28:05 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 19, 2021, 08:19:01 PM
post Idea for QCW DRSSTC
[Dual Resonant Solid State Tesla coils (DRSSTC)]
AstRii
September 19, 2021, 07:58:09 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 19, 2021, 03:16:40 PM
post Re: Driverless MOSFET SSTC
[Beginners]
AstRii
September 19, 2021, 01:32:47 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 19, 2021, 10:15:24 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Magneticitist
September 19, 2021, 06:32:18 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
September 19, 2021, 06:06:44 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
September 19, 2021, 04:14:18 AM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
Magneticitist
September 18, 2021, 11:33:37 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AstRii
September 18, 2021, 10:42:45 PM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal