Author Topic: SSTC - PCB design  (Read 338 times)

Offline Przemekk00

  • High Voltage Enthusiast
  • *
  • Posts: 8
  • Karma: +0/-0
    • View Profile
SSTC - PCB design
« on: September 10, 2022, 06:58:13 PM »
Hi,
Recently i decided to give another try and build Mads's SSTC 2. Last time i had problems with proper working at voltages higher than 130VDC (transistors were being destroyed due to crossconduction or gate voltage spikes, hard to say). Reducing bridge leakage inductance and adding snubber capacitor gave some positive results - it was able to work at around 220VDC, but it's still long way to rectified mains voltage (320V). This time i decided to make it look more professional and design a PCB and since it's my first circuit layout with use of computer software I want to get some opinions about my design, and what should I change if it's necessary.

Photos: https://mega.nz/folder/VqJDmSxI#ZC-xRg52OImkEYI395y0Vw




Offline davekni

  • High Voltage Expert
  • ******
  • Posts: 1806
  • Karma: +88/-1
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Re: SSTC - PCB design
« Reply #1 on: September 10, 2022, 11:51:07 PM »
Generally looks good.  Nice use of copper planes!

I'd recommend that every IC have at least one bypass capacitor on its supply pin.  For the high-current UCC driver chips, two caps is recommended, one for each VDD pin (pin 1 and pin 8).

Great work on your first ECB!
David Knierim

Offline Mads Barnkob

  • Administrator
  • Executive Board Member
  • *****
  • Posts: 2025
  • Karma: +53/-0
  • Denmark
    • View Profile
    • Kaizer Power Electronics
Re: SSTC - PCB design
« Reply #2 on: September 11, 2022, 07:03:52 AM »
Use of two sided board and parallel DC bus planes on the power section is already super great!

You could take a look at the similar DRSSTC driver PCB designs, which are free and open to all, get some inspiration here: https://highvoltageforum.net/index.php?topic=353.0

I got a few comments:
Green boxes: Your power traces got components too far from each other, minimize your circuit paths in high current circuits.
Blue box: The respect distance between potentials and legs are too small, for no reason, you got plenty of space to make it larger. Switching transients and being in a high voltage EMF, makes a Tesla coil circuit more exposed to such failures.
Gray box: Components are too spread out and track lines are too thin, for no reason.

Make room or rotate your voltage regulators, to have a heat sink mounted.
Do not have electrolytic capacitors too near to heat sources.

Aesthetically I only use 45 degree bends on tracks, no Y forks or 90 degree bends around pins. But that is not important :)


https://kaizerpowerelectronics.dk - Tesla coils, high voltage, pulse power, audio and general electronics
https://www.youtube.com/KaizerPowerElectronicsDk60/join - Please consider supporting the forum, websites and youtube channel!

Offline Przemekk00

  • High Voltage Enthusiast
  • *
  • Posts: 8
  • Karma: +0/-0
    • View Profile
Re: SSTC - PCB design
« Reply #3 on: September 12, 2022, 03:00:32 PM »
I added a few bypass capacitors, made tracks thicker, decreased distance between componets and changed footprint of GDT - mosfet gate connections. New screenshots are labeled as v2 in same mega.nz folder.

Offline davekni

  • High Voltage Expert
  • ******
  • Posts: 1806
  • Karma: +88/-1
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Re: SSTC - PCB design
« Reply #4 on: September 14, 2022, 06:38:17 AM »
Quote
I added a few bypass capacitors, made tracks thicker, decreased distance between componets and changed footprint of GDT - mosfet gate connections. New screenshots are labeled as v2 in same mega.nz folder.
Good improvements.  A couple more suggestions:
Bypass capacitors are placed well for U3, U4, and U5, adjacent power pin.  U2 and U6 would be better with bypass capacitors moved to adjacent their power pins.  Also, traces from power pins to bypass capacitors should be wide to minimize inductance.
I think Mads suggestion is to increase gaps between traces and planes in the power section.  That is probably a global parameter or a parameter on each of the plane rectangles, what space to provide around pins and traces.  I worry less about that than Mads does since this is only 320V and using 500V FETs.  Spikes much above 500V will be clamped by FET avalanche breakdown (or damage the FET if long enough) rather than cause arcing on the ECB.  However, some increase in clearance distance would be a good idea to make sure.
David Knierim

Offline Przemekk00

  • High Voltage Enthusiast
  • *
  • Posts: 8
  • Karma: +0/-0
    • View Profile
Re: SSTC - PCB design
« Reply #5 on: September 22, 2022, 12:39:51 PM »
Thank you for your help, beside circuit layout I increased gate resistance to 15 ohms to supress oscilations in exchange for rise and fall time. I also added a ferrite bead (RRH-40-20-100) to every transistor. Turns out it was enough and coil works properly at 320V DC.

High Voltage Forum

Re: SSTC - PCB design
« Reply #5 on: September 22, 2022, 12:39:51 PM »

 


* Recent Topics and Posts

post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
Today at 10:28:54 PM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
TiagoBS
Today at 05:32:02 PM
post Re: Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
55#sofcopper
Today at 04:39:00 PM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Max
Today at 10:28:42 AM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
Today at 04:49:55 AM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Max
Today at 12:32:58 AM
post Re: RF mosfets and laser generation
[Light, Lasers and Optics]
dru
October 03, 2022, 11:29:26 PM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Alberto
October 03, 2022, 10:43:21 PM
post Re: Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
MRMILSTAR
October 03, 2022, 10:22:59 PM
post Re: Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
klugesmith
October 03, 2022, 08:18:40 PM
post Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
55#sofcopper
October 03, 2022, 07:36:49 PM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
rikkitikkitavi
October 03, 2022, 05:20:17 PM
post Re: RF mosfets and laser generation
[Light, Lasers and Optics]
Da_Stier
October 03, 2022, 10:26:07 AM
post RF mosfets and laser generation
[Light, Lasers and Optics]
dru
October 03, 2022, 03:31:12 AM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
klugesmith
October 03, 2022, 01:57:50 AM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
davekni
October 03, 2022, 01:45:48 AM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
dru
October 03, 2022, 12:17:07 AM
post Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
dru
October 03, 2022, 12:14:34 AM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Mads Barnkob
October 02, 2022, 08:10:51 PM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Alberto
October 02, 2022, 05:47:51 PM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
rikkitikkitavi
October 02, 2022, 05:31:05 PM
post Re: Radiometer Copenhagen OSG 42b Oscilloscope Repair, From The 1950'ish
[Laboratories, Equipment and Tools]
rikkitikkitavi
October 02, 2022, 05:27:23 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
October 02, 2022, 02:24:19 PM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Mads Barnkob
October 02, 2022, 01:11:56 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
October 02, 2022, 04:48:00 AM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
October 02, 2022, 12:46:19 AM
post are these small guys flybacks?
[Transformer (Ferrite Core)]
Alberto
October 01, 2022, 10:13:29 PM
post My audio modulated sstc circuit, an easy one for beginners
[Solid State Tesla Coils (SSTC)]
dru
September 30, 2022, 08:05:55 PM
post Re: [WTS] large selection of IGBT bricks, large electrolytic capacitors
[Sell / Buy / Trade]
dbach
September 30, 2022, 04:17:35 PM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
davekni
September 30, 2022, 05:01:14 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 30, 2022, 04:46:59 AM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
TiagoBS
September 29, 2022, 10:23:27 PM
post [WTS] (EU) electrolytic caps 4700uF + film caps 30uF
[Sell / Buy / Trade]
costas_p
September 29, 2022, 10:13:52 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
JCF
September 29, 2022, 05:36:58 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Anders Mikkelsen
September 29, 2022, 12:05:51 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 29, 2022, 05:18:23 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
September 28, 2022, 08:28:16 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
JCF
September 28, 2022, 06:05:46 PM
post Re: controlling the negative gate bias voltage of the Gate drive transformer
[Dual Resonant Solid State Tesla coils (DRSSTC)]
prabhatkumar
September 28, 2022, 05:16:13 PM
post Re: DC charging solution
[Spark Gap Tesla Coils (SGTC)]
davekni
September 28, 2022, 05:43:34 AM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
davekni
September 28, 2022, 05:20:55 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 28, 2022, 05:15:19 AM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
dru
September 27, 2022, 07:11:42 PM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
dru
September 27, 2022, 07:07:00 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
JCF
September 27, 2022, 05:08:45 PM
post DC charging solution
[Spark Gap Tesla Coils (SGTC)]
Conrad73
September 27, 2022, 04:57:38 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 27, 2022, 03:12:49 AM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
klugesmith
September 27, 2022, 02:23:44 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 26, 2022, 07:55:31 PM
post Re: Help with PLL induction heater driver
[Electronic Circuits]
dbach
September 26, 2022, 04:04:11 PM
post Re: What am I missing?!?!?
[Spark Gap Tesla Coils (SGTC)]
davekni
September 26, 2022, 05:13:23 AM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 26, 2022, 05:10:13 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 26, 2022, 05:03:46 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 26, 2022, 04:33:12 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 26, 2022, 03:01:21 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 26, 2022, 01:30:04 AM
post Re: Help with PLL induction heater driver
[Electronic Circuits]
Anders Mikkelsen
September 25, 2022, 10:57:23 PM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 25, 2022, 09:59:53 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
September 25, 2022, 09:43:24 PM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
davekni
September 25, 2022, 07:33:57 PM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 25, 2022, 07:06:33 PM
post What am I missing?!?!?
[Spark Gap Tesla Coils (SGTC)]
Conrad73
September 25, 2022, 06:35:43 PM
post Radiometer Copenhagen OSG 42b Oscilloscope Repair, From The 1950'ish
[Laboratories, Equipment and Tools]
Mads Barnkob
September 25, 2022, 03:18:22 PM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
Rafft
September 25, 2022, 02:53:30 PM
post Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
dru
September 25, 2022, 09:05:37 AM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
September 25, 2022, 08:29:09 AM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 25, 2022, 05:27:41 AM
post Re: Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
klugesmith
September 25, 2022, 02:12:21 AM
post Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
September 25, 2022, 01:50:45 AM
post Re: controlling the negative gate bias voltage of the Gate drive transformer
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 24, 2022, 09:36:58 PM
post Re: Gate drive transformer with negative gate bias voltage
[Dual Resonant Solid State Tesla coils (DRSSTC)]
prabhatkumar
September 24, 2022, 06:56:35 AM
post Re: Gate drive transformer with negative gate bias voltage
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 24, 2022, 06:09:03 AM
post Re: Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
davekni
September 24, 2022, 01:32:08 AM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
September 23, 2022, 10:55:21 PM
post Re: Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
AstRii
September 23, 2022, 10:39:13 PM
post controlling the negative gate bias voltage of the Gate drive transformer
[Dual Resonant Solid State Tesla coils (DRSSTC)]
prabhatkumar
September 23, 2022, 05:48:17 PM
post Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
Peregrine
September 23, 2022, 02:01:10 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2022, 03:04:31 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 22, 2022, 04:15:36 PM
post Re: SSTC - PCB design
[Beginners]
Przemekk00
September 22, 2022, 12:39:51 PM
post Re: Possible Leads on Single Photon Camera
[General Chat]
alan sailer
September 22, 2022, 12:05:55 AM
post Re: Possible Leads on Single Photon Camera
[General Chat]
Mads Barnkob
September 21, 2022, 10:32:29 PM
post Possible Leads on Single Photon Camera
[General Chat]
alan sailer
September 21, 2022, 03:57:38 PM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
davekni
September 21, 2022, 05:50:15 AM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
RoamingD
September 20, 2022, 10:29:41 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
Mads Barnkob
September 20, 2022, 08:24:30 PM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
TiagoBS
September 20, 2022, 06:23:54 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 20, 2022, 05:20:07 AM
post Re: TO247 mounting
[Beginners]
davekni
September 20, 2022, 05:15:35 AM
post Re: MidiStick V2.0: Next gen tesla coil interrupter
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
TMaxElectronics
September 19, 2022, 11:43:47 PM
post Re: TO247 mounting
[Beginners]
Weston
September 19, 2022, 09:58:56 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
September 19, 2022, 09:05:35 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
RoamingD
September 19, 2022, 12:58:35 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 19, 2022, 12:13:46 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 19, 2022, 12:09:22 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 18, 2022, 11:38:51 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 18, 2022, 10:41:54 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
davekni
September 18, 2022, 10:31:32 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
RoamingD
September 18, 2022, 10:09:33 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 18, 2022, 09:58:34 PM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal