Author Topic: Getting last joules out of batteries  (Read 302 times)

Offline klugesmith

  • High Voltage Senior
  • *****
  • Posts: 517
  • Karma: +16/-0
    • View Profile
Getting last joules out of batteries
« on: September 09, 2022, 07:24:33 PM »
Cordless mouse on this PC failed a few minutes ago, and I suspected its battery. 
Swapped the battery, a single AA cell, with one in a quartz-regulated, analog-faced wall clock.

Apparently the mouse needs less juice than the clock.
Mouse is working fine with ex-clock battery.
Clock second hand is barely twitching with ex-mouse battery, even with clock in horizontal plane.
Normal failure in a wall-mounted clock leaves the seconds hand pointing to 9, and clock runs longer if laid flat.

Has anyone here tried a "joule thief" LED blinker circuit,
with a battery at the point of failing in mouse or clock service?

« Last Edit: September 09, 2022, 07:28:40 PM by klugesmith »

Offline davekni

  • High Voltage Expert
  • ******
  • Posts: 1806
  • Karma: +88/-1
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Re: Getting last joules out of batteries
« Reply #1 on: September 10, 2022, 06:22:11 AM »
Quote
Apparently the mouse needs less juice than the clock.
Much lower peak current required by mouse, but higher average current.  Mechanical clocks fail mostly due to battery internal resistance.
David Knierim

Offline Weston

  • High Voltage Technician
  • ***
  • Posts: 123
  • Karma: +11/-0
    • View Profile
Re: Getting last joules out of batteries
« Reply #2 on: September 14, 2022, 10:36:37 PM »
There have been one (or more?) attempted products to use a joule thief like circuit to extend battery life in existing products. I don't think any of them were commercially successful https://en.wikipedia.org/wiki/Batteroo_Boost

There is also not that much energy remaining in the end of the battery discharge curve. If the issues is ESR I don't think a boost converter would help much but I wonder if a large capacitor would help.

Regardless, the joule thef is a fun electronics project and circuit to analyze as a circuit design problem. I remember one of my first electronics projects in middle school was a joule theif based flash light using a a small common mode choke I pulled out of a power supply. I was quite proud of it until I think someone stole it on a school trip.

More recently I made a jfet based joule theif that could start up and light a LED down to a ~40mV input, which was enough to be powered by a flame and a few type K thermcouples!

The open source SKY130 PDK has some zero threshold mosfets so I was considering making a similar energy harvesting circuit and submitting it to one of the open source IC tapeouts, but I am a bit burnt out on IC design stuff at the moment.



« Last Edit: September 14, 2022, 10:38:26 PM by Weston »

Offline klugesmith

  • High Voltage Senior
  • *****
  • Posts: 517
  • Karma: +16/-0
    • View Profile
Re: Getting last joules out of batteries
« Reply #3 on: September 15, 2022, 11:18:56 PM »
Nice work, Weston.
In case this drifts into "useful engineering with very low voltage"...

Thermocouples are ubiquitous in gas valves for appliances with standing pilot lights.

A single junction (IIRC it's type T or J, with constantan on one side) generates about 25 mV.  That powers a solenoid to hold gas valve open, opposed by a spring that closes valve if pilot light is not burning.  The holding current requirement (with magnetic circuit closed) is much less than the pull-in current.  That's why, when lighting the pilot, one needs to keep mechanical button pressed until thermocouple is hot enough.

The solenoid stands as an example about wire windings in general.  Designer selects wire diameter, to trade between voltage and current, with no change in power requirement or coil dimensions or ampere-turns.  For the gas valve it's a few turns of thick wire, to run on 25 mV.
« Last Edit: September 15, 2022, 11:43:52 PM by klugesmith »

Offline rikkitikkitavi

  • High Voltage Technician
  • ***
  • Posts: 115
  • Karma: +2/-0
    • View Profile
Re: Getting last joules out of batteries
« Reply #4 on: October 02, 2022, 05:31:05 PM »
I thought that pilot flames where some kind of bi-metal that you need to mechanically push into the flame with the push button, and when heated by the flame it of course bends, and then maintains valve open by some mechanical contraption?

A man can not have too many variacs

Offline davekni

  • High Voltage Expert
  • ******
  • Posts: 1806
  • Karma: +88/-1
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Re: Getting last joules out of batteries
« Reply #5 on: October 03, 2022, 01:45:48 AM »
Quote
I thought that pilot flames where some kind of bi-metal that you need to mechanically push into the flame with the push button, and when heated by the flame it of course bends, and then maintains valve open by some mechanical contraption?
That seems like a logical alternative too.  The couple gas heaters I've personally used were thermocouple/solenoid.
David Knierim

Offline klugesmith

  • High Voltage Senior
  • *****
  • Posts: 517
  • Karma: +16/-0
    • View Profile
Re: Getting last joules out of batteries
« Reply #6 on: October 03, 2022, 01:57:50 AM »
In my experience, the bimetal bending parts are only for thermostatic control of main burner valve. (in a semiconductor-free water heater control).  There may be systems that work as Rikki described.

The conventional safety interlock has a poppet valve, normally held closed by a spring, which blocks all gas flow.

To light the pilot, step one is to push and holds a mechanical button which
1) opens the valve all the way
2) closes the magnetic circuit of a very-low-low voltage solenoid.  Holding voltage requirement may be 0.015 or 0.020 V.

The job of thermocouple, heated by the pilot flame, is to give the solenoid enough ampere-turns to hold the valve open when mechanical button is released.  Jump to 2:30 in video if URL doesn't do that.
/>
An easy physics demonstration employs a hand-held solenoid unit mated to a thermocouple. Push the plunger in, watch it pop right out.   Heat thermocouple with a lighter flame until the plunger stays in when pushed all the way.   Voltage and current metering may add value for EE nerds, but are not trivial.
« Last Edit: October 03, 2022, 02:12:05 AM by klugesmith »

Offline rikkitikkitavi

  • High Voltage Technician
  • ***
  • Posts: 115
  • Karma: +2/-0
    • View Profile
Re: Getting last joules out of batteries
« Reply #7 on: October 03, 2022, 05:20:17 PM »
Ok, cool. I bow to your knowledge. Smarter every day (thanks Destin for your programs) due to this forum

 Definiately some cunning engineering applying physics.

A man can not have too many variacs

High Voltage Forum

Re: Getting last joules out of batteries
« Reply #7 on: October 03, 2022, 05:20:17 PM »

 


* Recent Topics and Posts

post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
TiagoBS
Today at 05:32:02 PM
post Re: Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
55#sofcopper
Today at 04:39:00 PM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Max
Today at 10:28:42 AM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
Today at 04:49:55 AM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Max
Today at 12:32:58 AM
post Re: RF mosfets and laser generation
[Light, Lasers and Optics]
dru
October 03, 2022, 11:29:26 PM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Alberto
October 03, 2022, 10:43:21 PM
post Re: Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
MRMILSTAR
October 03, 2022, 10:22:59 PM
post Re: Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
klugesmith
October 03, 2022, 08:18:40 PM
post Is this a pulse cap
[Spark Gap Tesla Coils (SGTC)]
55#sofcopper
October 03, 2022, 07:36:49 PM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
rikkitikkitavi
October 03, 2022, 05:20:17 PM
post Re: RF mosfets and laser generation
[Light, Lasers and Optics]
Da_Stier
October 03, 2022, 10:26:07 AM
post RF mosfets and laser generation
[Light, Lasers and Optics]
dru
October 03, 2022, 03:31:12 AM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
klugesmith
October 03, 2022, 01:57:50 AM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
davekni
October 03, 2022, 01:45:48 AM
post Re: Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
dru
October 03, 2022, 12:17:07 AM
post Audio modulation questions, chords
[Dual Resonant Solid State Tesla coils (DRSSTC)]
dru
October 03, 2022, 12:14:34 AM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Mads Barnkob
October 02, 2022, 08:10:51 PM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Alberto
October 02, 2022, 05:47:51 PM
post Re: Getting last joules out of batteries
[Laboratories, Equipment and Tools]
rikkitikkitavi
October 02, 2022, 05:31:05 PM
post Re: Radiometer Copenhagen OSG 42b Oscilloscope Repair, From The 1950'ish
[Laboratories, Equipment and Tools]
rikkitikkitavi
October 02, 2022, 05:27:23 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
October 02, 2022, 02:24:19 PM
post Re: are these small guys flybacks?
[Transformer (Ferrite Core)]
Mads Barnkob
October 02, 2022, 01:11:56 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
October 02, 2022, 04:48:00 AM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
October 02, 2022, 12:46:19 AM
post are these small guys flybacks?
[Transformer (Ferrite Core)]
Alberto
October 01, 2022, 10:13:29 PM
post My audio modulated sstc circuit, an easy one for beginners
[Solid State Tesla Coils (SSTC)]
dru
September 30, 2022, 08:05:55 PM
post Re: [WTS] large selection of IGBT bricks, large electrolytic capacitors
[Sell / Buy / Trade]
dbach
September 30, 2022, 04:17:35 PM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
davekni
September 30, 2022, 05:01:14 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 30, 2022, 04:46:59 AM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
TiagoBS
September 29, 2022, 10:23:27 PM
post [WTS] (EU) electrolytic caps 4700uF + film caps 30uF
[Sell / Buy / Trade]
costas_p
September 29, 2022, 10:13:52 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
JCF
September 29, 2022, 05:36:58 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Anders Mikkelsen
September 29, 2022, 12:05:51 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 29, 2022, 05:18:23 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
September 28, 2022, 08:28:16 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
JCF
September 28, 2022, 06:05:46 PM
post Re: controlling the negative gate bias voltage of the Gate drive transformer
[Dual Resonant Solid State Tesla coils (DRSSTC)]
prabhatkumar
September 28, 2022, 05:16:13 PM
post Re: DC charging solution
[Spark Gap Tesla Coils (SGTC)]
davekni
September 28, 2022, 05:43:34 AM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
davekni
September 28, 2022, 05:20:55 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 28, 2022, 05:15:19 AM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
dru
September 27, 2022, 07:11:42 PM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
dru
September 27, 2022, 07:07:00 PM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
JCF
September 27, 2022, 05:08:45 PM
post DC charging solution
[Spark Gap Tesla Coils (SGTC)]
Conrad73
September 27, 2022, 04:57:38 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 27, 2022, 03:12:49 AM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
klugesmith
September 27, 2022, 02:23:44 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 26, 2022, 07:55:31 PM
post Re: Help with PLL induction heater driver
[Electronic Circuits]
dbach
September 26, 2022, 04:04:11 PM
post Re: What am I missing?!?!?
[Spark Gap Tesla Coils (SGTC)]
davekni
September 26, 2022, 05:13:23 AM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 26, 2022, 05:10:13 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 26, 2022, 05:03:46 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 26, 2022, 04:33:12 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 26, 2022, 03:01:21 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 26, 2022, 01:30:04 AM
post Re: Help with PLL induction heater driver
[Electronic Circuits]
Anders Mikkelsen
September 25, 2022, 10:57:23 PM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 25, 2022, 09:59:53 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
September 25, 2022, 09:43:24 PM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
davekni
September 25, 2022, 07:33:57 PM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 25, 2022, 07:06:33 PM
post What am I missing?!?!?
[Spark Gap Tesla Coils (SGTC)]
Conrad73
September 25, 2022, 06:35:43 PM
post Radiometer Copenhagen OSG 42b Oscilloscope Repair, From The 1950'ish
[Laboratories, Equipment and Tools]
Mads Barnkob
September 25, 2022, 03:18:22 PM
post Re: Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
Rafft
September 25, 2022, 02:53:30 PM
post Recommended development boards for QCWDRSSTC
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
dru
September 25, 2022, 09:05:37 AM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
September 25, 2022, 08:29:09 AM
post Re: Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 25, 2022, 05:27:41 AM
post Re: Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
klugesmith
September 25, 2022, 02:12:21 AM
post Ud failure
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
September 25, 2022, 01:50:45 AM
post Re: controlling the negative gate bias voltage of the Gate drive transformer
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 24, 2022, 09:36:58 PM
post Re: Gate drive transformer with negative gate bias voltage
[Dual Resonant Solid State Tesla coils (DRSSTC)]
prabhatkumar
September 24, 2022, 06:56:35 AM
post Re: Gate drive transformer with negative gate bias voltage
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 24, 2022, 06:09:03 AM
post Re: Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
davekni
September 24, 2022, 01:32:08 AM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
September 23, 2022, 10:55:21 PM
post Re: Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
AstRii
September 23, 2022, 10:39:13 PM
post controlling the negative gate bias voltage of the Gate drive transformer
[Dual Resonant Solid State Tesla coils (DRSSTC)]
prabhatkumar
September 23, 2022, 05:48:17 PM
post Gauss meter for strong magnetic fields
[Laboratories, Equipment and Tools]
Peregrine
September 23, 2022, 02:01:10 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 23, 2022, 03:04:31 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 22, 2022, 04:15:36 PM
post Re: SSTC - PCB design
[Beginners]
Przemekk00
September 22, 2022, 12:39:51 PM
post Re: Possible Leads on Single Photon Camera
[General Chat]
alan sailer
September 22, 2022, 12:05:55 AM
post Re: Possible Leads on Single Photon Camera
[General Chat]
Mads Barnkob
September 21, 2022, 10:32:29 PM
post Possible Leads on Single Photon Camera
[General Chat]
alan sailer
September 21, 2022, 03:57:38 PM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
davekni
September 21, 2022, 05:50:15 AM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
RoamingD
September 20, 2022, 10:29:41 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
Mads Barnkob
September 20, 2022, 08:24:30 PM
post Re: Driverless Single Mosfet Relay interrupted SSTC? - [All kinds of problems]
[Solid State Tesla Coils (SSTC)]
TiagoBS
September 20, 2022, 06:23:54 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 20, 2022, 05:20:07 AM
post Re: TO247 mounting
[Beginners]
davekni
September 20, 2022, 05:15:35 AM
post Re: MidiStick V2.0: Next gen tesla coil interrupter
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
TMaxElectronics
September 19, 2022, 11:43:47 PM
post Re: TO247 mounting
[Beginners]
Weston
September 19, 2022, 09:58:56 PM
post Re: Some questions about my first drsstc.
[Dual Resonant Solid State Tesla coils (DRSSTC)]
mthome4
September 19, 2022, 09:05:35 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
RoamingD
September 19, 2022, 12:58:35 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 19, 2022, 12:13:46 AM
post Re: MMC capacitor crash
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 19, 2022, 12:09:22 AM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 18, 2022, 11:38:51 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 18, 2022, 10:41:54 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
davekni
September 18, 2022, 10:31:32 PM
post Re: Musical interrupter problems
[Solid State Tesla Coils (SSTC)]
RoamingD
September 18, 2022, 10:09:33 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
September 18, 2022, 09:58:34 PM
post Re: UD2.7 dual Purpose Use
[Dual Resonant Solid State Tesla coils (DRSSTC)]
FonziDaytona
September 18, 2022, 08:45:21 PM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal