Author Topic: Rheostat or ???  (Read 1262 times)

Offline abstruse1

  • High Voltage Technician
  • ***
  • Posts: 131
  • Karma: +1/-0
    • View Profile
Rheostat or ???
« on: March 24, 2022, 04:14:46 PM »
I'm using an inductive heater driver to drive the FB that runs my CW multiplier, powered by 5, 12v SLA batteries in series. I can tap the battery bank wherever I want to for varing voltages at 12 v. intervals.

The driver is rated for 48 vdc input, but I use up to 60 vdc for short periods while monitoring the temperatures of the MOSFETS and resistors.  I've been using a large 15 ohm rheostat to vary the voltage (mostly used in the <6 ohn range).  Amps run around 15 (~900 watts).  I paralled an 8 ohm fixed resistor with the rheo to spread the load across more windings.

My rheostat gets really hot and, in one case, flashed the windings at one end.

Large, low resistance rheostats are hard to find and expensive.  I suppose that's because they're becoming obsolete in favor of semiconductor devices.

My question is, are there semiconductor devices that would work for me?  Thanx!
Abstruse1
   Been working with electricity for 60 years and still getting a tingle!

Offline klugesmith

  • High Voltage Senior
  • *****
  • Posts: 707
  • Karma: +22/-0
    • View Profile
Re: Rheostat or ???
« Reply #1 on: March 24, 2022, 06:45:45 PM »
You could replace rheostat with power transistors operating in linear region.   But they would dissipate just as much power as the rheostat, and fail at junction temperatures that would not bother the rheostat.  Might be easier to cool your rheostat with fans, air blowers, or oil immersion.

Or you could make a duty-cycle-controlled dimmer, using power transistors driven to very low resistance when ON.   That would be a respectable engineering project by itself.

How about an array of big power resistors that are switched in or out of the circuit?

I don't understand the circuit and purpose of your rheostat to "vary the voltage".   Is it in series with the battery, which you are switching in steps of 12 volts?  Is there no power control knob on your inductive heater driver?

Offline abstruse1

  • High Voltage Technician
  • ***
  • Posts: 131
  • Karma: +1/-0
    • View Profile
Re: Rheostat or ???
« Reply #2 on: March 24, 2022, 07:25:45 PM »
Nope, no pwr control on driver.

I've thought about an array of power resistors, and that would work, but not cheap.

Yes, I pick the voltage from the battery box (usually 60) and run that in series with the rheo.  That way, I can tune the voltage to  the driver to whatever I want.

I also thought about a hefty bridge rectifier with capacitor to change the output of my Variac (an honest-to-god old one) to D.C.  Would that work?
Abstruse1
   Been working with electricity for 60 years and still getting a tingle!

Offline MRMILSTAR

  • High Voltage Senior
  • *****
  • Posts: 564
  • Karma: +20/-0
  • Cedar Rapids, Iowa
    • View Profile
Re: Rheostat or ???
« Reply #3 on: March 24, 2022, 08:04:51 PM »
You could use a variac with rectifier and smoothing capacitor if the current rating of the variac is high enough. I don't know how much current your multiplier needs but I would shoot for at least a 10 amp variac. You would have to be very careful adjusting the variac though. One small mis-adjustment of the knob and you could easily fry the MOSFETs in you ZVS driver with over-voltage.

Unless you have a real need for fine adjustment for your voltage multiplier I would just stick with your batteries. They already give you 12 volt tap points. I would select 24, 36, or 48 volts and be done with it.

Have you actually measured the AC output of your flyback transformers? You don't want to exceed 1/2 the voltage rating of the capacitors. Maybe 24, 36, or 48 volts already will yield that maximum AC voltage. My 14-stage VM only needed 30 volts to achieve the maximum safe voltage for my capacitors.
Steve White
Cedar Rapids, Iowa
Retired electrical engineer

High Voltage Forum

Re: Rheostat or ???
« Reply #3 on: March 24, 2022, 08:04:51 PM »

 


* Recent Topics and Posts

post Re: Pulse Power High Current Discharges from 3 Phase PFC Capacitors
[Capacitor Banks]
MRMILSTAR
Today at 05:22:43 AM
post Re: Want to build HV HF oscilloscope probe.
[Electronic Circuits]
Twospoons
Today at 05:08:46 AM
post Re: Pulse Power High Current Discharges from 3 Phase PFC Capacitors
[Capacitor Banks]
davekni
Today at 04:49:16 AM
post Re: Ring Launcher AC vs DC?
[Induction Launchers, Coil Guns and Rails guns]
FPS
Today at 03:55:37 AM
post Re: Want to build HV HF oscilloscope probe.
[Electronic Circuits]
klugesmith
Today at 02:48:22 AM
post Re: Want to build HV HF oscilloscope probe.
[Electronic Circuits]
Domo
Today at 02:05:05 AM
post Re: Plasma Torid - Class E Self Resonant Dual/Stereo - Plasma Torid Build
[Dual Resonant Solid State Tesla coils (DRSSTC)]
alan sailer
Today at 01:43:10 AM
post Re: Want to build HV HF oscilloscope probe.
[Electronic Circuits]
Twospoons
May 18, 2024, 11:30:11 PM
post Re: Pulse Power High Current Discharges from 3 Phase PFC Capacitors
[Capacitor Banks]
MRMILSTAR
May 18, 2024, 10:10:56 PM
post Want to build HV HF oscilloscope probe.
[Electronic Circuits]
Domo
May 18, 2024, 09:46:17 PM
post Re: Pulse Power High Current Discharges from 3 Phase PFC Capacitors
[Capacitor Banks]
davekni
May 18, 2024, 08:05:36 PM
post Re: Help an EE student
[General Chat]
Twospoons
May 18, 2024, 05:59:21 AM
post Re: What capacitor configuration to explode foil?
[Capacitor Banks]
MRMILSTAR
May 18, 2024, 05:44:41 AM
post Re: RDRSSTC - Project Build
[Dual Resonant Solid State Tesla coils (DRSSTC)]
ZakW
May 18, 2024, 01:55:42 AM
post Re: What capacitor configuration to explode foil?
[Capacitor Banks]
klugesmith
May 17, 2024, 11:49:33 PM
post Re: Pulse Power High Current Discharges from 3 Phase PFC Capacitors
[Capacitor Banks]
MRMILSTAR
May 17, 2024, 10:18:46 PM
post Pulse Power High Current Discharges from 3 Phase PFC Capacitors
[Capacitor Banks]
Mads Barnkob
May 17, 2024, 07:24:22 PM
post Re: What capacitor configuration to explode foil?
[Capacitor Banks]
Mads Barnkob
May 17, 2024, 07:14:35 PM
post Re: Help an EE student
[General Chat]
Mads Barnkob
May 17, 2024, 08:35:38 AM
post Re: Help an EE student
[General Chat]
MRMILSTAR
May 17, 2024, 05:34:10 AM
post Re: colored 50 Ohm coax
[General Chat]
Da_Stier
May 16, 2024, 10:53:53 PM
post Re: Help an EE student
[General Chat]
Michelle_
May 16, 2024, 10:37:50 PM
post Re: Help an EE student
[General Chat]
davekni
May 16, 2024, 10:29:30 PM
post Re: Help an EE student
[General Chat]
klugesmith
May 16, 2024, 08:26:41 PM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
davekni
May 16, 2024, 06:54:05 PM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
NyaaX_X
May 16, 2024, 05:04:41 PM
post Re: Tesla Synth Player for Syntherrupter
[Computers, Microcontrollers, Programmable Logic, Interfaces and Displays]
AntoineRcbs
May 16, 2024, 12:13:47 PM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
Domo
May 16, 2024, 06:58:12 AM
post Re: New EE student asks about Cutting-Edge fields
[General Chat]
davekni
May 16, 2024, 06:47:09 AM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
NyaaX_X
May 16, 2024, 06:00:49 AM
post Re: New EE student asks about Cutting-Edge fields
[General Chat]
Twospoons
May 16, 2024, 05:45:08 AM
post Re: New EE student asks about Cutting-Edge fields
[General Chat]
davekni
May 16, 2024, 05:03:41 AM
post Re: DRSSTC grounding issues
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
May 16, 2024, 04:58:40 AM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
davekni
May 16, 2024, 04:36:40 AM
post Re: colored 50 Ohm coax
[General Chat]
klugesmith
May 16, 2024, 12:28:27 AM
post Re: Watercooling
[Dual Resonant Solid State Tesla coils (DRSSTC)]
acobaugh
May 15, 2024, 11:13:48 PM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
klugesmith
May 15, 2024, 10:58:05 PM
post colored 50 Ohm coax
[General Chat]
Da_Stier
May 15, 2024, 08:31:48 PM
post Re: DRSSTC grounding issues
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
May 15, 2024, 07:56:38 PM
post Re: DRSSTC grounding issues
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
May 15, 2024, 06:29:59 PM
post Re: Watercooling
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Felix B.
May 15, 2024, 04:04:14 PM
post Re: Schmitt trigger schematic question
[Electronic Circuits]
Michelle_
May 15, 2024, 03:32:57 PM
post DRSSTC grounding issues
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Felix B.
May 15, 2024, 03:07:39 PM
post New EE student asks about Cutting-Edge fields
[General Chat]
samsonwilliams
May 15, 2024, 05:50:59 AM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
Domo
May 15, 2024, 05:38:14 AM
post Re: Schmitt trigger schematic question
[Electronic Circuits]
Benjamin Lockhart
May 15, 2024, 04:58:02 AM
post Re: Big Coil Build Log
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
May 15, 2024, 04:34:49 AM
post Re: Watercooling
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
May 15, 2024, 04:30:18 AM
post Re: Watercooling
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Benjamin Lockhart
May 15, 2024, 04:00:55 AM
post Re: Watercooling
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
May 15, 2024, 03:21:51 AM
post Re: Schmitt trigger schematic question
[Electronic Circuits]
Michelle_
May 14, 2024, 11:12:22 PM
post Re: Schmitt trigger schematic question
[Electronic Circuits]
Benjamin Lockhart
May 14, 2024, 11:00:00 PM
post Schmitt trigger schematic question
[Electronic Circuits]
Michelle_
May 14, 2024, 09:45:38 PM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
klugesmith
May 14, 2024, 09:02:28 PM
post Re: Small-ish 3D printed SGTC via cheap ZVS flyback build, humbly asking a couple ?s
[Spark Gap Tesla Coils (SGTC)]
Michelle_
May 14, 2024, 05:55:24 AM
post Re: Weird AC/DC mini SSTC build review
[Solid State Tesla Coils (SSTC)]
Michelle_
May 14, 2024, 05:44:12 AM
post Re: Small-ish 3D printed SGTC via cheap ZVS flyback build, humbly asking a couple ?s
[Spark Gap Tesla Coils (SGTC)]
MRMILSTAR
May 14, 2024, 05:11:54 AM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
alan sailer
May 13, 2024, 11:44:56 PM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
Domo
May 13, 2024, 10:28:34 PM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
alan sailer
May 13, 2024, 10:20:19 PM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
Domo
May 13, 2024, 09:27:58 PM
post Re: Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
alan sailer
May 13, 2024, 09:06:59 PM
post Help with primary voltages of unknown transformer
[Transformer (Ferrite Core)]
Domo
May 13, 2024, 08:43:49 PM
post Re: Benjamin's DRSSTC 2 in progress
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Benjamin Lockhart
May 13, 2024, 07:25:29 PM
post Re: Plasma Torid - Class E Self Resonant Dual/Stereo - Plasma Torid Build
[Dual Resonant Solid State Tesla coils (DRSSTC)]
OmGigaTron
May 13, 2024, 06:50:59 PM
post Re: Weird AC/DC mini SSTC build review
[Solid State Tesla Coils (SSTC)]
Michelle_
May 13, 2024, 03:47:08 PM
post Re: Small-ish 3D printed SGTC via cheap ZVS flyback build, humbly asking a couple ?s
[Spark Gap Tesla Coils (SGTC)]
Michelle_
May 13, 2024, 03:42:58 PM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
NyaaX_X
May 13, 2024, 07:09:16 AM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
davekni
May 13, 2024, 05:02:46 AM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
NyaaX_X
May 13, 2024, 02:25:25 AM
post Re: Plasma Torid - Class E Self Resonant Dual/Stereo - Plasma Torid Build
[Dual Resonant Solid State Tesla coils (DRSSTC)]
alan sailer
May 13, 2024, 01:39:11 AM
post Re: Plasma Toroid
[Solid State Tesla Coils (SSTC)]
alan sailer
May 13, 2024, 01:33:21 AM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
davekni
May 12, 2024, 10:56:53 PM
post Re: Quick question about steve ward mini SST5 resonant frequency
[Solid State Tesla Coils (SSTC)]
NyaaX_X
May 12, 2024, 05:10:40 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
Michelle_
May 12, 2024, 04:24:44 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
alan sailer
May 12, 2024, 04:10:54 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
Michelle_
May 12, 2024, 04:04:11 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
hal7rr
May 12, 2024, 03:56:57 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
Michelle_
May 12, 2024, 03:46:45 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
hal7rr
May 12, 2024, 02:59:16 PM
post Re: Quick question about steve ward mini SST5 resonant frequency
[Solid State Tesla Coils (SSTC)]
Michelle_
May 12, 2024, 02:51:27 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
Michelle_
May 12, 2024, 02:49:42 PM
post Re: Quick question about steve ward mini SST5 resonant frequency
[Solid State Tesla Coils (SSTC)]
ZakW
May 12, 2024, 08:34:39 AM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
ZakW
May 12, 2024, 08:30:29 AM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
Michelle_
May 12, 2024, 02:35:17 AM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
alan sailer
May 12, 2024, 02:07:32 AM
post Re: Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
Michelle_
May 11, 2024, 09:55:59 PM
post Re: Help with LabCoatz's Staccato QCW DRSSTC
[Beginners]
NyaaX_X
May 11, 2024, 06:16:22 PM
post Help with LabCoatz's Staccato QCW DRSSTC Tesla Coil
[Beginners]
hal7rr
May 11, 2024, 05:24:34 PM
post Re: Type 77 Metglas Laced Ferrite Core
[General Chat]
NyaaX_X
May 11, 2024, 10:39:24 AM
post Re: Type 77 Metglas Laced Ferrite Core
[General Chat]
Mads Barnkob
May 11, 2024, 07:02:20 AM
post Re: Aluminum electrolytic capacitor ripple current issue
[Beginners]
NyaaX_X
May 11, 2024, 06:40:50 AM
post Type 77 Metglas Laced Ferrite Core
[General Chat]
paulp1776
May 11, 2024, 06:23:59 AM
post Re: Weird AC/DC mini SSTC build review
[Solid State Tesla Coils (SSTC)]
Michelle_
May 11, 2024, 05:27:22 AM
post Re: Quick question about steve ward mini SST5 resonant frequency
[Solid State Tesla Coils (SSTC)]
alan sailer
May 11, 2024, 01:37:37 AM
post Re: designing and building electron gun help!
[General Chat]
Twospoons
May 11, 2024, 12:10:44 AM
post designing and building electron gun help!
[General Chat]
Luca c.
May 10, 2024, 09:38:05 PM
post Re: Quick question about steve ward mini SST5 resonant frequency
[Solid State Tesla Coils (SSTC)]
Michelle_
May 10, 2024, 09:24:21 PM
post Re: Quick question about steve ward mini SST5 resonant frequency
[Solid State Tesla Coils (SSTC)]
alan sailer
May 10, 2024, 08:43:11 PM
post Quick question about steve ward mini SST5 resonant frequency
[Solid State Tesla Coils (SSTC)]
Michelle_
May 10, 2024, 08:33:47 PM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal