Author Topic: Driverless SSTC  (Read 369 times)

Offline bismallah

  • High Voltage Enthusiast
  • *
  • Posts: 1
  • Karma: +0/-0
    • View Profile
Driverless SSTC
« on: November 26, 2021, 11:59:27 PM »
I tried following the circuit from Labcoatz for a driverless SSTC but couldn't limit the current properly. I tried using a 375W ballast which I measured to be 4.4H across the primary, and nothing happened which I think is due to the high reactance? The ballast itself is shown below and in order to properly use it should I short the secondary (I saw some do this with microwave transformers)? I also tried using two 40W lightbulbs in parallel in place of a ballast, and the secondary coil produced a measly 120V (should I try a higher wattage setup?).
Anyway, I tried the circuit without a ballast and it worked for a bit before abruptly dying. The tesla coil build and schematics are shown below, can someone please help?

Online davekni

  • High Voltage Expert
  • ******
  • Posts: 1439
  • Karma: +70/-0
  • Physicist, engineer (electronic), and hobbiest
    • View Profile
Re: Driverless SSTC
« Reply #1 on: November 28, 2021, 12:32:09 AM »
Slayer oscillators like this are simple, but also finicky.

As with most electronic circuits, wire length causes problems.  Wires have inductance.  Tight layout and construction is required.  Especially the 1.5ke12 diode needs to be soldered directly to the FET.  1.5ke400 should also be fairly close.

There are plenty of counterfeit IRFP460 parts available.  I have no experience with "Bojack".  Their FETs may or may not have the robustness of normal industry vendors such as Vishay/Siliconix.

If you have access to a variac or other way to reduce voltage, I'd start below 120V.
David Knierim

Offline Andrew321

  • High Voltage Enthusiast
  • *
  • Posts: 44
  • Karma: +1/-0
    • View Profile
Re: Driverless SSTC
« Reply #2 on: December 09, 2021, 04:12:30 AM »
I had some success with this circuit a while back. I wasn't able to get it to work at rectified mains because I couldn't seem to find a big enough inductor in my garage. I have a variac though and just started it at 12VDC and took it up to max current input. I think it was around 45VAC input for my setup. Still got some big parks off it, maybe 4 to 6"! Then I tried to audio modulate it with a 555 timer and ALMOST got it to work. but all my mosfets hated it and were killed :(

I could be misremembering, but make sure you have your coil directions correct. If noting is happening, try flipping your primary connections around. Also, as Dave mentioned, shorten long leads. I've had stuff not work for the life of me until I put the alligator clips away and soldered everything tight. Then it works like a charm!

Good luck!

High Voltage Forum

Re: Driverless SSTC
« Reply #2 on: December 09, 2021, 04:12:30 AM »

 


* Recent Topics and Posts

post 120VAC Mains Ramped Builds
[Solid State Tesla Coils (SSTC)]
Magneticitist
Today at 03:00:04 AM
post Re: Muon Decay
[Detection, Counting and Measurements]
alan sailer
Today at 02:16:57 AM
post Re: Help on my "first" SSTC (LabCoatz SSTC 2.0)- Popping transistors
[Solid State Tesla Coils (SSTC)]
TiagoBS
January 20, 2022, 06:56:35 PM
post Re: Muon Decay
[Detection, Counting and Measurements]
Da_Stier
January 20, 2022, 05:19:26 PM
post Re: Muon Decay
[Detection, Counting and Measurements]
alan sailer
January 20, 2022, 03:53:54 PM
post Re: Muon Decay
[Detection, Counting and Measurements]
Uspring
January 20, 2022, 01:20:19 PM
post Re: Muon Decay
[Detection, Counting and Measurements]
Da_Stier
January 20, 2022, 10:11:21 AM
post Re: Muon Decay
[Detection, Counting and Measurements]
alan sailer
January 19, 2022, 08:22:49 PM
post Re: Muon Decay
[Detection, Counting and Measurements]
Mads Barnkob
January 19, 2022, 06:49:36 PM
post Re: Etching PCBs with a SLA 3d printer
[Printed Circuit Board]
hardboiled99
January 19, 2022, 07:37:27 AM
post Primary Coil Winding Technique
[Solid State Tesla Coils (SSTC)]
alan sailer
January 18, 2022, 10:34:48 PM
post Re: Muon Decay
[Detection, Counting and Measurements]
alan sailer
January 18, 2022, 08:46:53 PM
post Re: Muon Decay
[Detection, Counting and Measurements]
Mads Barnkob
January 18, 2022, 08:08:53 PM
post Re: GDT Testing
[Solid State Tesla Coils (SSTC)]
ZakW
January 18, 2022, 07:15:22 PM
post Muon Decay
[Detection, Counting and Measurements]
alan sailer
January 18, 2022, 06:49:48 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 18, 2022, 08:47:53 AM
post Re: QO-100 / EShail 2 Uplink amplifier development adventures
[Radio Frequency]
Da_Stier
January 17, 2022, 09:13:32 PM
post Re: QO-100 / EShail 2 Uplink amplifier development adventures
[Radio Frequency]
Da_Stier
January 17, 2022, 09:05:56 PM
post Re: Help on my "first" SSTC (LabCoatz SSTC 2.0)- Popping transistors
[Solid State Tesla Coils (SSTC)]
Mads Barnkob
January 17, 2022, 07:45:48 PM
post Re: General Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
January 17, 2022, 07:41:34 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
Mads Barnkob
January 17, 2022, 07:38:25 PM
post Re: SSTC with push-pull configuration
[Solid State Tesla Coils (SSTC)]
Mads Barnkob
January 17, 2022, 07:31:03 PM
post Re: GDT Testing
[Solid State Tesla Coils (SSTC)]
Mads Barnkob
January 17, 2022, 07:28:02 PM
post Re: Induction heater Driver for Flyback?
[Voltage Multipliers]
MRMILSTAR
January 16, 2022, 09:00:02 PM
post Induction heater Driver for Flyback?
[Voltage Multipliers]
abstruse1
January 16, 2022, 07:35:26 PM
post Re: SSTC with push-pull configuration
[Solid State Tesla Coils (SSTC)]
Bambinz
January 16, 2022, 12:21:40 PM
post Re: SSTC with push-pull configuration
[Solid State Tesla Coils (SSTC)]
davekni
January 15, 2022, 07:10:03 PM
post Re: SSTC with push-pull configuration
[Solid State Tesla Coils (SSTC)]
Bambinz
January 15, 2022, 06:31:33 PM
post Re: SSTC with push-pull configuration
[Solid State Tesla Coils (SSTC)]
Magneticitist
January 14, 2022, 08:47:43 PM
post Re: SSTC with push-pull configuration
[Solid State Tesla Coils (SSTC)]
davekni
January 14, 2022, 08:39:07 PM
post Re: Unusual Youtube channel activity
[General Chat]
davekni
January 14, 2022, 08:14:17 PM
post Re: Unusual Youtube channel activity
[General Chat]
Mads Barnkob
January 14, 2022, 08:12:13 PM
post Unusual Youtube channel activity
[General Chat]
MRMILSTAR
January 14, 2022, 05:51:52 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 14, 2022, 08:51:57 AM
post Re: SSTC with push-pull configuration
[Solid State Tesla Coils (SSTC)]
Bambinz
January 13, 2022, 08:20:02 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
davekni
January 13, 2022, 05:27:40 AM
post Re: General Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
thedoc298
January 13, 2022, 03:10:32 AM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 12, 2022, 06:18:15 PM
post Re: Single mosfet bifiliar gdt
[Solid State Tesla Coils (SSTC)]
alan sailer
January 12, 2022, 05:45:26 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
MRMILSTAR
January 12, 2022, 03:29:04 PM
post Re: Help with SSTC feedback circuits with 4046 IC and Schmitt Triggers
[Solid State Tesla Coils (SSTC)]
AFreshLad
January 12, 2022, 01:30:38 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 12, 2022, 09:09:13 AM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
MRMILSTAR
January 11, 2022, 08:05:27 PM
post Re: Nokia Siemens 3G Flexi 2100MHz 50W Amplifier Teardown
[Radio Frequency]
Mads Barnkob
January 11, 2022, 07:42:12 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
Duane B
January 11, 2022, 07:33:15 PM
post Re: 8x MOT transformer, weird power draw
[Transformer (Iron Core)]
AstRii
January 11, 2022, 06:19:49 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 11, 2022, 05:19:46 PM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
MRMILSTAR
January 11, 2022, 04:31:28 PM
post Re: 8x MOT transformer, weird power draw
[Transformer (Iron Core)]
AstRii
January 11, 2022, 03:21:37 PM
post Re: GDT Testing
[Solid State Tesla Coils (SSTC)]
davekni
January 11, 2022, 06:50:49 AM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
Duane B
January 11, 2022, 06:34:20 AM
post Re: Help on my "first" SSTC (LabCoatz SSTC 2.0)- Popping transistors
[Solid State Tesla Coils (SSTC)]
davekni
January 11, 2022, 06:24:13 AM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
davekni
January 11, 2022, 06:15:08 AM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
MRMILSTAR
January 11, 2022, 05:25:31 AM
post Re: Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
Duane B
January 11, 2022, 12:07:22 AM
post Strange reading for grid feedback coil voltage
[Vacuum Tube Tesla Coils (VTTC)]
MRMILSTAR
January 10, 2022, 10:56:48 PM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
Duane B
January 10, 2022, 09:38:53 PM
post Re: Help on my "first" SSTC (LabCoatz SSTC 2.0)- Popping transistors
[Solid State Tesla Coils (SSTC)]
ZakW
January 10, 2022, 07:50:13 PM
post Re: GDT Testing
[Solid State Tesla Coils (SSTC)]
ZakW
January 10, 2022, 07:19:17 PM
post Re: Help on my "first" SSTC (LabCoatz SSTC 2.0)- Popping transistors
[Solid State Tesla Coils (SSTC)]
TiagoBS
January 10, 2022, 03:13:08 PM
post Re: GDT Testing
[Solid State Tesla Coils (SSTC)]
davekni
January 10, 2022, 04:21:46 AM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 10, 2022, 03:59:09 AM
post Re: 8x MOT transformer, weird power draw
[Transformer (Iron Core)]
davekni
January 10, 2022, 03:54:59 AM
post Re: GDT Testing
[Solid State Tesla Coils (SSTC)]
ZakW
January 09, 2022, 11:45:09 PM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
jpvvv123
January 09, 2022, 11:04:25 PM
post 8x MOT transformer, weird power draw
[Transformer (Iron Core)]
AstRii
January 09, 2022, 04:22:11 PM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
Duane B
January 09, 2022, 05:52:11 AM
post Re: GDT Testing
[Solid State Tesla Coils (SSTC)]
davekni
January 09, 2022, 05:10:50 AM
post Re: Performance issues regarding phase angle in SSTCs
[Solid State Tesla Coils (SSTC)]
davekni
January 09, 2022, 01:20:40 AM
post GDT Testing
[Solid State Tesla Coils (SSTC)]
ZakW
January 09, 2022, 12:38:28 AM
post Re: General Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
January 08, 2022, 06:36:28 PM
post Performance issues regarding phase angle in SSTCs
[Solid State Tesla Coils (SSTC)]
Max Seiringer
January 08, 2022, 03:21:31 PM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 08, 2022, 09:05:41 AM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
jpvvv123
January 07, 2022, 10:20:10 PM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
304er
January 07, 2022, 05:56:28 PM
post Re: First SSTC based on profdc9 PCB Pack
[Solid State Tesla Coils (SSTC)]
davekni
January 07, 2022, 05:15:38 AM
post Re: DRSSTC tuning
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
January 07, 2022, 05:01:21 AM
post Re: How to prevent secondary to secondary to primary arcs?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
davekni
January 07, 2022, 04:59:59 AM
post Tophat QCW 1
[Dual Resonant Solid State Tesla coils (DRSSTC)]
dbach
January 07, 2022, 02:27:35 AM
post How to prevent secondary to secondary to primary arcs?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
dbach
January 07, 2022, 02:19:40 AM
post Re: General Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Mads Barnkob
January 06, 2022, 09:33:06 PM
post Re: First SSTC based on profdc9 PCB Pack
[Solid State Tesla Coils (SSTC)]
alan sailer
January 06, 2022, 06:09:39 PM
post Re: DRSSTC tuning
[Dual Resonant Solid State Tesla coils (DRSSTC)]
kubajed
January 06, 2022, 04:48:22 PM
post Re: First SSTC based on profdc9 PCB Pack
[Solid State Tesla Coils (SSTC)]
SK1701
January 06, 2022, 03:05:55 PM
post Re: General Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
AstRii
January 06, 2022, 08:17:09 AM
post General Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
January 06, 2022, 04:42:25 AM
post Re: Hi! 811 A tesa coil
[Vacuum Tube Tesla Coils (VTTC)]
jpvvv123
January 06, 2022, 03:40:43 AM
post Re: First SSTC based on profdc9 PCB Pack
[Solid State Tesla Coils (SSTC)]
alan sailer
January 06, 2022, 12:18:38 AM
post First SSTC based on profdc9 PCB Pack
[Solid State Tesla Coils (SSTC)]
SK1701
January 05, 2022, 08:37:13 PM
post Re: Bus Supply Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Hydron
January 04, 2022, 05:58:10 PM
post Re: Bus Supply Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
AstRii
January 04, 2022, 01:37:02 PM
post Bus Supply Questions
[Dual Resonant Solid State Tesla coils (DRSSTC)]
flyingperson23
January 04, 2022, 04:12:34 AM
post Re: ZVS Driven Teslacoil
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Andrew321
January 04, 2022, 01:14:26 AM
post WTS: small secondary coils
[Sell / Buy / Trade]
dbach
January 03, 2022, 05:38:08 PM
post Re: 60hz synchronous motor on 50hz?
[Spark Gap Tesla Coils (SGTC)]
klugesmith
January 02, 2022, 01:17:37 AM
post Re: 60hz synchronous motor on 50hz?
[Spark Gap Tesla Coils (SGTC)]
paulj
January 01, 2022, 06:53:46 PM
post Re: Single mosfet bifiliar gdt
[Solid State Tesla Coils (SSTC)]
MHV
January 01, 2022, 06:39:05 PM
post DC powered coil. best topology?
[Dual Resonant Solid State Tesla coils (DRSSTC)]
Rafft
January 01, 2022, 02:05:43 PM
post Re: Full Bridge SSTC
[Solid State Tesla Coils (SSTC)]
Rafft
January 01, 2022, 11:54:25 AM
post Re: 60hz synchronous motor on 50hz?
[Spark Gap Tesla Coils (SGTC)]
klugesmith
December 31, 2021, 09:50:59 PM

Sitemap 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 
SimplePortal 2.3.6 © 2008-2014, SimplePortal